2019 BMW X3

I bought my 2019 BMW X3 late 2025 before Christmas. The Carfax was fine and there were no open recalls on the vehicle. The vehicle had been serviced regularly at BMW facilities. Our family mechanic looked at the vehicle before I bought it and performed some basic diagnostics. The vehicle appeared fine. There were no error codes and all of the fluids were topped off. I don't know if the issues with the coolant were there before I purchased the vehicle or if they happened afterwards. There were no warning lights and everything looked good. This car is garage kept and is used a couple of times a week. I did my research on the internet and took my car in for an oil change at a highly-rated independent auto repair facility that specializes in European vehicles and are famous for providing dealership-level expertise, ASE-certified with factory trained technicians from Germany. On March 5th, 2026, when I went to pick up my car, they told me the bad news that is a well known manufacturer defect within the industry regarding these vehicles. They used plastic components in the engine compartment and in the cooling system, which makes the vehicles malfunction. From their report, with pictures, they state the following repairs need to be made, "During the vehicle inspection noticed active coolant leaks are present from multiple locations. The radiator plastic tank actively leaking coolant. The water pump change over valve leaking coolant. The turbocharger coolant line has a coolant crud build up . Oil filter housing and coolant flange on the cylinder block are discolored. For proper cooling system repair recommend complete update of the cooling system. Both balance shaft end caps leaking oil. Recommend replacement during cooling system update." They quoted me $8,914.86 for this repair. That's over HALF the value of the vehicle. They said the entire system needs to be replaced because ALL of the plastic parts in Florida's hot sun will fail. Sudden coolant failures in FL = DEATH.

I am submitting this complaint regarding a serious mechanical and safety issue involving my 2019 BMW X3. On or around January 21, 2024, while driving from my home, a warning signal suddenly appeared on my dashboard related to the vehicle’s cooling system/engine. Due to safety concerns, I pulled into a nearby Wawa parking lot, which was the safest available place to stop at the time. I turned the vehicle off and waited approximately 15 minutes before carefully driving the vehicle back home. After inspection and diagnosis, I was informed that the vehicle required extensive repairs, including an engine replacement and cooling system repairs. At the time the coolant warning appeared, the replacement engine reportedly had approximately 59 miles on it. I believe a sudden engine or cooling system malfunction while operating a vehicle presents a serious safety concern for drivers, passengers, and others on the roadway. In addition, I experienced issues involving the shark fin antenna on the vehicle, which I understand may be connected to broader complaints involving BMW vehicles. I am requesting that NHTSA review this matter to determine whether these issues may indicate a broader defect or safety-related concern affecting other consumers. I am willing to provide supporting documentation including repair invoices, dealership records, photographs, and any additional information requested. Thank you for your attention to this matter and for your commitment to vehicle safety.

While driving our BMW 2019 X3 on the highway, other drivers honked to get my attention that our vehicle's rear hatch was partially open. When we came to a stop light, I had my son riding in the passenger seat press the hatch button on the key fob to close the hatch. Instead this fully opened the back hatch. We continued pressing the fob button in an attempt to get the hatch to close without having to exit the vehicle. Rather than exit the vechicle in the middle of the roadway, we drove about 50 yards until we could pull over safely. A motorcyclist had been following us, and came up behind and communicated that he wanted to press the button to close the hatch. After I gave my consent, he pressed the close button and the hatch closed and latched. My husband has previously had incidents where after parking the BMW, he finds the back hatch open. He's also researched online this is apparently an issue. Reference: [XXX] NHTSA claim XXX INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My SOS system has failed due to tsp/atm module defect from faulty shark fin component. My vehicle is off line and im unable to receive emergency services in case of an emergent situation.

Rear caliper locking up when in reverse. Knocking noise and crunching sound.

My 2019 BMW X3 equipped with a B46 engine developed a significant coolant leak at approximately 80,000 miles. The vehicle displayed a low coolant warning, and coolant was visibly leaking underneath the vehicle. Around the same time, I began noticing excessive white exhaust/steam during cold starts and, for the first time since owning the vehicle, had to add engine oil between scheduled oil changes. The vehicle is currently undergoing inspection by an independent repair facility. Preliminary findings indicate concerns involving premature failure of critical plastic cooling system and/or oil filter housing components. Based on my research, these failures appear consistent with widespread complaints involving BMW B46/B48 engine cooling system and oil filter housing defects. I am concerned this defect could lead to sudden coolant loss, overheating, engine failure, or unsafe driving conditions. Prior to the coolant warning appearing, there were no significant alerts indicating a major or imminent cooling system failure. The apparent failure of critical plastic engine cooling components under normal driving conditions raises serious concerns regarding the durability and safety of these parts. I have photographs documenting the coolant leak, as well as detailed notes and diagnostic information from the repair facility, available upon request. The vehicle is available for inspection.

Our 2019 BMW X3 M40i shows "EMERGENCY CALL SYSTEM MALFUNCTION" which means the "SOS" system, which is crucial for post-collision response, fails. Erhardt BMW in Bloomfield Hills, Michigan confirmed water leakage due to defective sealing around the roof-mounted shark fin antenna damaged the Telematics Control Box (TCB) and now requires replacement. The estimated cost is $3,600. Some quick research revealed this to be a repeated problem with my vehicle. BMW has acknowledged it as a defect in 2017-2023 model year BMW M440i, M550i, X1, X3, X4, X5, X6, X7, 330, 340i and 750i vehicles and fix it at no cost, but only for citizens of [XXX] , as reported by [XXX] of [XXX] . For details, see: [XXX] . This seems unfair to non [XXX] residents like me [XXX] ). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I'm reporting a safety issue with BMW vehicles equipped with the B58 engine, primarily 2019-2021 models. These vehicles have an oil pump with an internal plastic component that regulates oil pressure, and this part is fracturing in the field, causing sudden loss of oil pressure. The failure typically occurs during cold starts in low temperatures. When it fails, oil pressure becomes erratic or is lost entirely, often with little to no warning before engine damage or vehicle disablement. Warning signs, when present, include inability to measure oil level electronically, abnormal oil pressure, or sudden drive train malfunction warnings. These can rapidly progress to engine shutdown or severe damage from oil starvation. This creates a dangerous situation because the vehicle can become disabled without warning while driving or after startup. This is especially hazardous when cars become immobilized in traffic or during winter conditions when failures occur most frequently, leaving occupants exposed to freezing temperatures while awaiting assistance. Pump replacement requires extensive disassembly and commonly costs $6,000-$8,000, assuming no engine damage. A critical concern: owners cannot determine if their vehicle has the original plastic pump or the later metal revision. BMW's VIN-based parts lookup now shows updated components even when original plastic parts remain installed, and BMW has removed the original plastic part number from dealer networks entirely. Failures are reported across multiple production years, and the scope of affected vehicles remains unclear. Because this condition causes sudden vehicle disablement without adequate warning, especially in cold weather, I believe this warrants investigation as a potential safety-related defect.

Main dashboard display is partially blocked by a message stating “emergency call system malfunction.” Apparently the roof mounted antenna’s seal fails and allows water into the electronics for the emergency call system. Upon failure, it also stops the Bluetooth microphone for the cell phone to stop working. The dealer quoted the repair at $3,200. Judging from a google search, this is a common problem among this generation of BMW vehicles.

The vehicle's Telematics Control Box (TCB), located beneath the roof-mounted shark fin antenna, failed due to water intrusion and internal corrosion. The failure produced the following fault codes confirmed by BMW of Norwood, MA: B7F341 (backup battery hardware defective), B7F33C (internal ECU error), and B7F327 (microphone short circuit to ground), along with cascading faults across multiple other vehicle modules. Symptoms included a persistent 'Emergency Call System Malfunction' warning on the instrument cluster, loss of GPS/navigation accuracy, and loss of odometer display. The shark fin antenna base seal — a foam tape and adhesive system — had likely deteriorated after approximately 6-7 years of service, consistent with a pattern of failures reported by numerous other owners of 2017-2023 BMW X1, X3, X4, X5, X6, X7, M440i, M550i, 330, 340i, and 750i vehicles. BMW dealer quoted $3,300 for repair. An independent BMW specialist quoted $3,500. BMW North America declined to cover the repair as the vehicle is out of warranty, despite acknowledging the issue as known. This failure mode is the subject of active class action litigation (Craft v. BMW of North America LLC, Case No. 1:24-cv-06826, U.S. District Court for the District of New Jersey) and an ongoing investigation by Sauder Schelkopf LLC on behalf of affected owners. SAFETY CONCERN: The failure disables the Intelligent Emergency Call system, which automatically contacts emergency services in the event of a serious accident. Additionally, the persistent warning obscures the instrument cluster including the odometer display, impairing normal vehicle operation. Water intrusion reaching vehicle electronics represents a broader safety risk if it propagates to safety-critical modules. ACTION REQUESTED: Formal investigation into the adequacy of the shark fin antenna sealing design across affected model years, and consideration of a recall or extended warranty to cover TCB replacement costs for affected owners.

I am reporting a water intrusion issue in my 2019 BMW X3 involving both the roof-mounted “shark fin” antenna and the sunroof. Water enters the vehicle during normal rain conditions and has caused failure of the emergency call (SOS) system. This presents a serious safety concern, as the emergency communication system may not function in the event of a crash or emergency. Water intrusion also creates a risk of electrical damage and potential malfunction of critical vehicle systems while driving. The vehicle has been properly maintained, and this issue appears to be related to known defects involving water leaks from roof components in BMW vehicles. The total repair cost to address these issues is $4,650.

While driving down the highway at about 60 mph, the vehicle made a loud noise like a gunshot, and the sunroof exploded. Fragments of glass fell from the sunroof onto the backseat and floor board and large chunks of glass fell after. There was not any indication that the sunroof was damaged prior to failure and there were no other cars around that could have caused a rock or other debris to fly up and hit the sunroof. Fragments of glass could have injured the driver and the noise startled the driver and could have caused a wreck.