Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2019 BMW Z4 — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every BMW Z4 year.
NHTSA warns this vehicle can catch fire while parked and switched off (1 recall). Park outside and away from structures until it is repaired.
Recalls are issued per model. Confirm whether this specific car has already been repaired using its VIN — free, at any franchised dealer or on nhtsa.gov/recalls.
NHTSA lists 6 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Risk: A short circuit in the starter relay may increase the risk of a fire.
Remedy: Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
Campaign 25V636000
Issue: BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
Risk: The lack of an image in the back-up camera display increases the risk of a crash.
Remedy: BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
Campaign 19V684000
Issue: BMW of North America, LLC (BMW) is recalling certain 2019-2020 330i, 330i xDrive, and 2019 Z4 vehicles. The needle roller bearings of the counterbalance shafts may have been improperly installed, potentially causing the counterbalance shaft to loosen.
Risk: If the counterbalance shaft loosens, severe engine damage could occur, increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the engine, free of charge. The recall began December 13, 2019. Owners may contact BMW customer service at 1-800-525-7417.
Campaign 19V732000
Issue: BMW of North America, LLC (BMW) is recalling certain 2019 Z4 sDrive30i, 2019-2020 330i xDrive, M340i and M340i xDrive, 2020 X3M and X4M, and Toyota Supra vehicles. In certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod.
Risk: A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.
Remedy: BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
Campaign 20V355000
Issue: BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.
Risk: Loss of braking assist can increase the risk of a crash.
Remedy: Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Campaign 21V598000
Issue: BMW of North America, LLC (BMW) is recalling certain 2019-2020 Z4 sDrive30i, Z4 M40i and 2020 Toyota Supra vehicles. The headlamps are able to be adjusted horizontally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices and Associated Equipment."
Risk: Should the headlamps be adjusted horizontally, there could be increased glare and reduced visibility for oncoming drivers, or reduced visibility for the vehicle operator, thereby increasing the risk of a crash.
Remedy: BMW will notify owners, and dealers will inspect the headlamp vertical and horizontal adjustment plugs, correcting them as necessary, free of charge. The recall began December 23, 2020. BMW owners may contact BMW customer service at 1-800-525-7417 or Toyota owners may contact Toyota customer service at 1-888-270-9371.
Campaign 20V516000
No EPA fuel-economy match for this model (naming may differ or it predates EPA records).
The parts named most often across 5 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
1 crash
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
The contact owns a 2019 BMW Z4. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
Reporting premature part fail. -The 2019 BMW has 14,300 miles. The vehicle recently failed VT state inspection for "Play in control arm ball joints" Normal ball joint replacement is usually in the 60,000 mile range. The 1st recommended check of steering components per BMW service manual is is "6th engine oil service (approx 60,000 miles)". There was no warning of the premature fail. The failed parts will be replaced and used parts preserved for inspection if needed.
My grill shutters are faulty and the problem has been persistent and the vehicle is only at 30,000 miles. This is the same part that was issued an extended service contract by BMW for various other models. I believe my model is rare enough to not be included but it should. The existing recall/warranty is “SIB 01 12 19 FRONT GRILLE UPPER/LOWER ACTIVE AIR FLAPS: LTD WTY EXT TO 15 YEARS/150,000 MILES” and I believe mine should be included in this as it is the same engine as these various models. The grill shutters are experiencing the same fault and they do not open and close properly as the models listed. I receive code P05AF which is signals the lower shutters are not closing.
The automatic emergency did not engage the brakes as described to by the dealer, BMW genius and the BMW website. The car was in a collision at low speed (under 35mph) with the car in front of me which put me at risk. BMW sent an engineer from N.J. to inspect the car. The is under warranty and it was in perfect working order. The engineer determined that the system did not engage because the accelerator was depressed, I was told that the system does not work when the accelerator is depressed but that is not how the system is advertised and it is not how it was described in ALL of the BMW marketing materials.
MY NEW CAR CHECK ENGINE LIGHT GOES ON AND I HAVE BOUGHT IT INTO SERVICE APPOX 5 TIMES. THE LIGHT GOES OFF AND WHEN I GET IT HOME IT GOES ON AGAIN WHEN I START THE CAR. I THOUGHT IT WAS FIXED. HOWEVER IT CAME ON AGAIN AND I AM AFRAID TO DRIVE IT.
Rated configuration: 2019 BMW Z4 C RWD