Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2004 Chevrolet Impala — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Chevrolet Impala year.
NHTSA lists 7 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Risk: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Campaign 15V701000
Issue: General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.
Risk: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.
Campaign 15V201000
Issue: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000
Issue: DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONS<SUP>TM</SUP>" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.
Risk: A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.
Remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.
Campaign 09E005000
Issue: DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.
Risk: IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.
Campaign 08E063000
Issue: CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
Risk: FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
Remedy: DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000
Issue: CERTAIN PASSENGER VEHICLES WERE PRODUCED WITH LOWER THAN SPECIFIED TORQUE ON BOTH FRONT BRAKE CALIPER TO STEERING KNUCKLE ATTACHMENT BOLTS. WITH IMPROPER TORQUE, THE CLAMP LOAD AT THE JOINT MAY NOT BE ADEQUATE TO PREVENT MOVEMENT BETWEEN THE CALIPER BRACKET AND KNUCKLE.
Risk: DEPENDING ON WHETHER ONE OR BOTH BOLTS BACKS OUT OR FRACTURES, THE RESULT CAN BE LOCKING OF THE AFFECTED WHEEL DURING BRAKING AND AN ABRUPT STEERING INPUT IN THE DIRECTION OF THE LOCKED WHEEL, REDUCED BRAKING AND NOISE FROM THE AFFECTED WHEEL, OR SEVERING OF A BRAKE HOSE, INCREASED BRAKE PEDAL TRAVEL, AND REDUCED STEERING CONTROL. REDUCED BRAKING OR STEERING CONTROL COULD CAUSE A CRASH.
Remedy: DEALERS ARE TO TIGHTEN BOTH BOLTS TO THE SPECIFIED TORQUE. OWNER NOTIFICATION BEGAN ON JUNE 28, 2004. OWNERS SHOULD CONTACT CHEVROLET 1-800-630-2438 OR PONTIAC 1-800-620-7668.
Campaign 04V287000
26.6 mpg average · 19–32 range · EPA says 22
Over 5 years this costs $3,000 more in fuel than an average new vehicle.
NHTSA frontal crash test
Rated configuration: 2004 Chevrolet Impala 4-DR w/SAB
The parts named most often across 1,071 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
2 crashes · 1 fire
1 fire
7 fires
1 crash · 1 fire · 1 injured
2 crashes
1 injured
1 crash · 1 fire · 1 injured
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
Cars acceleration causes me to be unable to pick up speed it decelerates up hills small or latg ramps cats constantly fly pass to avoid a multi car pile up it’s very dangerous!
The contact owns a 2004 Chevrolet Impala. The contact stated that while driving approximately 40 MPH, the vehicle suddenly decelerated to approximately 20 MPH, and the instrument panel went black. The contact stated that the vehicle lost power steering functionality, and then lost motive power and stalled. The contact was assisted by persons nearby to push the vehicle to the side of the road. The vehicle was towed to a mechanic, who was unable to determine the cause of the failure. The vehicle was towed to the dealer, but was not diagnosed. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 71,000.
The contact owned a 2004 Chevrolet Impala. The contact received notification of NHTSA Campaign Number: 14V400000 (Electrical System) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.
Wiring harness has got hot and cause a short not getting fuel and more
The contact owns a 2004 Chevrolet Impala. The contact stated while driving approximately 40 MPH, the vehicle lost motive power. The contact was able to pull over and restart the vehicle after waiting approximately 5-10 minutes. The contact stated that the check engine warning light was illuminated. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 15V701000 (Engine and Engine Cooling) however, the VIN was not included. The vehicle was taken to a local dealer but was awaiting diagnostic testing. The manufacturer was not informed of the failure. The failure mileage was approximately 130,000.
TL* THE CONTACT OWNED A 2014 CHEVEROLET IMPALA. THE CONTACT STATED WHILE DRIVING AT 65 MPH AND WHEN THE CONTACT WAS EXITING OFF THE EXIT RAMP, THE VEHICLE STALLED. THE CONTACT TRIED TO RESTART THE VEHICLE BUT FAILED. THE CONTACT WAS ATTEMPTED TO PUSH THE VEHICLE TO SIDE OF THE ROAD WHEN THEY NOTICED SMOKE COMING FROM THE FRONT OF THE HOOD. THE CONTACT OPENED THE HOOD AND SAW A FIRE COMING FROM THE UNDERNEATH THE ENGINE. NO ONE WAS INJURED. THE FIRE DEPARTMENT CAME AND EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THERE WAS A BATTERY WARNING LIGHT ILLUMINATED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO CHARITY TOWING AND RECOVERY (4106 S 7TH ST, PHOENIX, AZ 85040) THE VEHICLE WAS NOT INSPECTED FOR CAUSED OF FAILURE. THE LOCAL DEALER OR THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
MY IGNITION SWITCH HAS A RECALL THAT SOMETIMES TAKES FOREVER TO GET KEY TO TURN OVER, THE STEERING SHAFT AND KNUCKLES ALSO HAVE A RECALL THAT MAKE ME DRIFT AND SLIDE ON DRY ROADS, ENGINE AND COOLING SYSTEM AS WELL HAS RECALL.
WHEN USING THE DRIVER'S SIDE FRONT SEAT BELT ON MY DAUGHTER'S CAR ON FRIDAY, 11/13/2020, THE METAL BELT CLIP CLICKS INTO THE BUCKLE WITH AN AUDIBLE CLICK. THIS APPEARS TO BE SAFELY ENGAGED, YET IF I TUG ON THE BELT, THE CLIP POPS OUT OF THE BUCKLE. I TRIED THIS REPEATEDLY AND HAD THE SAME EXPERIENCE EACH TIME. MY DAUGHTER TOLD ME THIS HAD BEEN OCCURRING FOR SEVERAL WEEKS. REALIZING THIS IS A SERIOUS SAFETY HAZARD THAT NEEDS TO BE ADDRESSED, I CALLED THE GM DEALER FOR HELP. THEY TOLD ME THE BUCKLE ASSEMBLY IS NO LONGER AVAILABLE TO BE REPLACED. I THEN CALLED GM DIRECTLY TO SEE ABOUT GETTING THIS PART AND TO REPORT THE SERIOUSNESS OF THIS SAFETY CONCERN. THEY CREATED A SERVICE REQUEST CASE NUMBER 9-6357435144. THEY IN TURN DIRECTED ME BACK TO THE DEALER I ORIGINALLY CALLED. THE DEALER'S SERVICE TECHNICIAN THEN SUGGESTED I GET A USED BELT BUCKLE FROM A JUNKYARD. I CALLED GM AGAIN AND THEY ATTEMPTED TO DIRECT ME AGAIN BACK TO THE ORIGINAL DEALER I HAD CALLED AND THEY CONNECTED ME TO PREVIOUSLY. WHEN I TOLD THEM I NEEDED TO HAVE THEM FIND THIS PART FOR ME, THEY SIMPLY DIRECTED ME TO ANOTHER NEARBY DEALER. WHEN SPEAKING TO THIS DEALER, THEY DID NOT HAVE THE BUCKLE ASSEMBLY ALSO, BUT WERE ABLE TO LOCATE OTHER DEALERS THAT HAD IT. IT WILL TAKE A WEEK FOR THIS PART TO ARRIVE. IN THE MEANTIME, MY DAUGHTER IS DRIVING IN THE TWIN CITIES WITHOUT A SEAT BELT AS IT IS DEFECTIVE. I PRAY SHE DOES NOT GET IN AN ACCIDENT AS IT IS WINTER IN MINNESOTA. PLEASE NOTIFY OTHER OWNERS OF THIS MODEL CAR THAT THEY MAY HAVE A SIMILAR BAD EXPERIENCE AND NOTIFY GM TO TAKE THIS PROBLEM MORE SERIOUSLY THAN THEY HAVE WITH ME SO FAR. RESPECTFULLY, GLEN WOLF
TL* THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE LOW OIL PRESSURE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT AFTER EXITING THE VEHICLE HE NOTICED AN OIL LEAK. THE VEHICLE WAS TOWED TO HIS RESIDENCE. WHILE INSPECTING THE VEHICLE, THE CONTACT BECAME AWARE THAT AN OIL LINE WAS DETACHED AND WAS VISIBLE FROM THE FRONT PASSENGER'S SIDE WHEEL WELL. THE OIL LINE WAS RE-ATTACHED. THE VEHICLE WAS TAKEN TO BOMNIN CHEVROLET MANASSAS LOCATED AT 8000 SUDLEY RD, MANASSAS, VA 20109, (571) 364-7245, AND THE SERVICE MANAGER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS THEN TAKEN TO INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 108,000.
TL* THE CONTACT OWNS A 2004 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START-UP ON SEVERAL OCCASIONS. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO DYER CHEVROLET FORT PIERCE (4200 S. US HWY 1, FORT PIERCE, FL 34982) AND THE CONTACT WAS INFORMED THAT THE PART WAS NOT YET AVAILABLE AND THAT SHE WOULD RECEIVE A CALL WHEN THE PARTS BECAME AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND INFORMED THE CONTACT THE PART WAS NOT AVAILABLE AND PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *BF
MY OIL KEEPS LEAKING OUT AND I HAVE TO KEEP ADDING TO IT. I'VE TRIED SEALANTS BUT NONE OF THEM WORK TO STOP IT FROM LEAKING AS WELL AS A SUSHI IN MY DASH. *TR
THE MUFFLER PIPE BROKE FROM UNDERNEATH THE CAR WHILE WE WERE DRIVING IT IN KESHENA, WI. AS WE WERE TRYING TO PULL THE VEHICLE OVER I COULD SEE SPARKS FROM IT UNDERNEATH THE CAR
Showing 12 of 1,071 complaints.