Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2004 Ford Expedition — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ford Expedition year.
NHTSA lists 4 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: CERTAIN TRADESONIC COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy: TRADESONIC WILL NOTIFY OWNERS AND REPLACE THE LAMPS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JULY 2006. OWNERS MAY CONTACT TRADESONIC AT 626-934-8884.
Campaign 06E064000
Issue: SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000
Issue: CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy: PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000
Issue: CERTAIN ANZO COMBINATION HEADLAMP ASSEMBLIES SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS WHICH FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: ANZO WILL NOTIFY OWNERS AND REPLACE THE HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN MAY 9, 2006. OWNERS MAY CONTACT ANZO USA AT 909-468-3688.
Campaign 06E023000
No EPA fuel-economy match for this model (naming may differ or it predates EPA records).
NHTSA frontal crash test
2 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2004 Ford Expedition 4-DR.
The parts named most often across 296 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
24 crashes · 1 fire · 38 injured · 1 death
7 crashes · 1 fire · 1 injured
3 fires · 1 injured
2 crashes · 9 injured
1 crash · 2 fires
4 fires
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
1 complaint-reported fatality on this model.
The contact owns a 2004 Ford Expedition. The contact recently purchased the vehicle and stated that while driving at an undisclosed speed, the transmission hesitated before upshifting with the accelerator pedal depressed. Additionally, while stopped at a traffic light, the vehicle rolled backwards when the accelerator pedal was depressed before responding as needed. There was no warning light illuminated. The contact attempted to return the vehicle to the independent dealer where the vehicle was purchased; however, the dealer declined to assist. Recently, the vehicle stalled, and it was towed to an independent mechanic to be diagnosed. The mechanic retrieved fault codes for the engine and stated that the TCM needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.
The contact owns a 2004 Ford Expedition. The contact stated that the turn signals, the hazard lights, and the cigarette lighter had become inoperable. The TPMS warning light was illuminated. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was unknown.
Just bought this truck I have no idea what has or has not been resolved, very poor lighting I noticed and there's a click noise coming from? It just clicks and clicks and clicks. Thanks
The contact owns a 2004 Ford Expedition. The contact stated while driving approximately 10 MPH, the vehicle lunged forward while depressing the accelerator pedal. The contact was unable to drive above 15 MPH because the vehicle became difficult to control. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to an independent mechanic who diagnosed and determined that the rear axle was fractured, the rear subframe was severely corroded, and the rear driver's side sway bar and rear differential were corroded. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was 110,665.
The contact owns a 2004 Ford Expedition. The contact stated while driving at 40 MPH, the vehicle shut down completely, and the warning messages indicated check gage and check service engine. The contact was able to pull over on the side of the road. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was 127,708.
The contact owns a 2004 Ford Expedition. The contact stated that while her daughter was driving at an undisclosed speed, the vehicle was jerking. The contact stated that one spark plug exploded and then another spark plug exploded and went through the cylinder head. The contact called the local dealer but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic where the spark plug was replaced. The manufacturer was notified and referred the contact to the NHTSA for assistance. The failure mileage was approximately 87,000.
Electrical fire today. Vehicle was parked outside garage. A clicking noise was heard and noticed the mirror was trying to move/click and car was filled with smoke. Mirror switches didn't work when tried. Knocked mirror off and fire stopped. Wiring Harness around the emergency brake area melted. Fire melted a hole in the dash corner by windshield. Vehicle was last driven about 25 hrs. earlier with no issues. Approx. 128K miles. Glad it wasn't in garage and the clicking was heard or garage/house would have burned. We haven't done anything to it yet.
Unknown, transmition left me stranded on busy highway. Managed to get it moved off the road before being hit. After getting it home and not driving for a period of time it can be started and moved with no issue. Drive to town no problem parked it to take care of some business and when I went to leave I couldn't back out of the parking place. Got it home and let it sit again. Needed to move it out of the way all was good started it and moved it across the yard and backed it in no problem. Had K&O auto look at it and was told it needs a transmission. I see allot of complaints about this issue from others without Ford being held responsible to correct the problem. Nice vehical said I can't afford to get it fixed, now driving a 500.00 used vehicle to get around, it is an eye sore but gets me around ok. Would rather enjoy the expidition if Ford would fix the issue that 1000's have had.
The contact owns a 2004 Ford Expedition. The contact stated while driving at various speeds, the vehicle lost motive power without warning and the steering wheel became difficult to steer on several occasions. The vehicle was taken to an independent mechanic, but the failure could not be replicated. The throttle was replaced however, the failure recurred. The manufacturer was not made aware of the failure. The failure mileage was 216,000. The Vin was not available.
VEHICLE LOST POWER FOR 3-5 SECONDS AT HIGHWAY SPEEDS APPROXIMATELY 65 MPH ON THREE SEPARATE EVENTS. VEHICLE SLOWED DOWN DUE TO POWER LOSS WHILE IN HEAVY TRAFFIC. THREE OTHER TIMES AT IDLE SPEED IN DRIVE AND IN PARK ENGINE STALLED AND IMMEDIATELY RESTARTED. LOSS OF POWER STEERING DUE TO ENGINE NOT RUNNING WHEN STALL EVENT HAPPENED. I PERFORMED INSPECTION OF FUEL PUMP RELAY WHICH IS INTERNAL TO PASSENGER SIDE FUSE BLOCK. FOUND INADEQUATE SOLDER JOINT ON INTEGRATED RELAY PRINTED CIRCUIT AND BURN MARKS ON OUTSIDE OF FUEL PUMP RELAY. LOCATED SALVAGE FUSE BLOCK SAME MAKE AND MODEL AND INSPECTED. SAME DAMAGE ON SALVAGE FUSE BLOCK ASSEMBLY. REPLACED WITH AFTERMARKET FUSE BLOCK WITH REVISED SOLDER JOINT AND UPDATED RELAY.
THE FRAME IS RUSTING. SEE PHOTOS. THE BODY IS RUSTING AWAY ALSO THE BRAKE LINES. THE ENTIRE VEHICLE IS RUSTING AWAY. WHY HAS THIS 2004 FORD NOT INCLUDED IN A RECALL FOR RUST.
TL* THE CONTACT OWNS A 2004 FORD EXPEDITION. THE CONTACT STATED WHILE VEHICLE WAS IN A STAND STILL THE VEHICLE WAS LEAKING OIL ON THE MUFFLER SYSTEM AND STARTER. THE CONTACT ALSO STATED WHILE DRIVING 25 MPH, A BURNING ODOR WAS DETECTED COMING FROM THE MUFFLER AREA. THE CONTACT STATED THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED A LOCAL DEALER WAS CONTACTED HOWEVER THE FAILURE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT HEAD GASKET WOULD NEED TO BE REPLACED. THE CONTACT STATED THAT THE FAILURE OCCURRED AT 75,000 MILES AND HE REPLACED THE HEAD GASKET. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 210,000.
Showing 12 of 296 complaints.