Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2009 Ford Explorer, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ford Explorer year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 1 recall for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
Risk: AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
Remedy: MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Campaign 10E043000
NHTSA frontal crash test
Rated configuration: 2009 Ford Explorer 4-DR. w/SAB
The parts named most often across 33 owner complaints filed with NHTSA for this make, model and year.
1 crash
2 crashes · 1 injured
1 crash · 2 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
TRANSMISSION WENT OUT WHILE DRIVING ON EXPRESSWAY SPEED LIMIT WAS75 MPH ON CRUISE CONTROL
MY CAR HAS AIRBAG LIGHT ON AND I HAVE CONSTANT PROBLEMS WITH THE FUEL SYSTEM, AND A FEW ELECTRICAL PROBLEMS.
SUV SEEMS TO BE IDLED DURING START UP OR EVEN WHEN DRIVING. SOUNDS AIRY LIKE ITS TRYING TO ACCELERATE. ALSO I HAVE HAD BREAK PADS REPLACED MORE THAN USUAL. MECHANIC SAID IT WAS REPORTED THAT THEY HAVE GONE OUT MORE THAN NORMAL. EACH TIME GOING OUT BEFORE WARRANTY EXPIRED. TODAY, CAR WAS PLACED IN REVERSE AND CAR SPENT OUT OF CONTROL SPINNING AROUND 3 TIMES BEFORE IT CAME TO A COMPLETE STOP BEFORE CRASHING INTO ANOTHER VEHICLE. THIS TOOK PLACE IN THE PARKING LOT OF WALMART. *TR
TL* THE CONTACT OWNS A 2009 FORD EXPLORER. THE CONTACT STATED THAT THE ENGINE STALLED NUMEROUS TIMES WITHOUT WARNING WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO TOWN AND COUNTRY FORD (5041 FORD PARKWAY, BESSEMER, ALABAMA 35022, (205)491-0000) WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY FAILED. THE DEALER REPLACED THE THROTTLE BODY, BUT THE VEHICLE CONTINUED TO STALL WHILE DRIVING VARIOUS SPEEDS. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 62,684. *TT CONSUMER STATED CAR WOULD STOP WITHOUT ANY WARNING. *JB
THROTTLE BODY ISSUES, INTERMITTENT STAHLS, PEDAL SURING FORWARD WHEN ACCELERATED. THIS IS A HUGE SAFETY RISK AND FROM WHAT I HAVE READ A DEFECT IN THE 2009 FORD MODELS. MY TRUCK IS IN THE MIDDLE OF THE REPAIR AND I DO NOT HAVE AN EXTENDED WARRANTY AND I BELIEVE FORD SHOULD PAY FOR THE EXPENSES OF REPAIRING THIS DEFECT.
THE SHIFTER DOES NOT STAY IN PLACE. THE CAR DOES NOT STAY IN GEAR. IT WILL ROLL BACKWARDS BECAUSE THE PIN IN SHIFTER IS NOT WORKING.
FORD: MY 2009 FORD EXPLORER EDDIE BAUER V6 EXHIBITS AN INTERMITTENT FAULT/ALARM WITH THE RSC SYSTEM WHILE DRIVING ON PUBLIC ROADS (STREET, FREEWAY, HIGHWAY). ALL THE INSTANCES OCCURRED HAD BEEN PROPERLY DOCUMENTED AND DISCUSSED WITH THE LOCAL FORD DEALER IN REPEATED VISITS THAT SHOULD BE DOCUMENTED ON THEIR BOOKS. IN ALL INSTANCES THE ALARM IS *** NOT *** REGISTERED IN THE NON-VOLATILE MEMORY (NVM) PORTION OF THE ON BOARD COMPUTER CODE IS B1432 CONTROL MODULE FAILURE
2009 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO WHEEL SEPARATION WHICH RESULTED IN AN AUTOMOBILE ACCIDENT. *LD *JS
IN MAY 2017 I HAD SERVICE PERFORMED ON MY 2009 FORD SUV (INCLUDING REPLACEMENT OF FRONT AND REAR BRAKE PADS AND TURN OF ALL FOUR ROTORS) AT MY LOCAL FORD DEALERSHIP. ON MAY 13, 2017, MYSELF, MY WIFE, AND OUR TWO CHILDREN (BOTH MINORS, AGES 2 AND 8) WERE INVOLVED IN A VEHICLE ACCIDENT DUE TO A WHEEL SEPARATION OF MY SERVICED FORD SUV. MY FORD SUV WAS TOWED BACK TO MY LOCAL FORD DEALERSHIP FOR REPAIRS. I WAS TOLD DAMAGE TO MY FORD SUV INCLUDED: 1) A FAILED WHEEL BEARING AND 2) ALL FIVE LUG NUTS ON THE DRIVER SIDE HAD SHEERED OFF. I WAS TOLD ALL PREVIOUS WORK PERFORMED ON MY FORD SUV FOLLOWED PROCEDURES ESTABLISHED BY FORD MOTOR COMPANY. I REQUESTED AN INVESTIGATION (BY MY LOCAL FORD DEALERSHIP) INTO THE CAUSE OF MECHANICAL FAILURES RESULTING IN THE VEHICLE ACCIDENT. AS OF MAY 30, 2017, NO INVESTIGATIVE FINDINGS WERE REPORTED TO ME; AND I AGAIN REQUESTED AN INVESTIGATION INTO THE CAUSE OF MECHANICAL FAILURES IN JUNE 2017, AND JULY 2017. AS OF AUGUST 2017, NO INVESTIGATIVE REPORT NOR FINDINGS WERE PROVIDED TO ME. I CONTACTED FORD MOTOR COMPANY AND REQUESTED AN INVESTIGATION INTO THE CAUSE OF MECHANICAL FAILURES OF MY FORD SUV INCLUDING A VEHICLE ACCIDENT RECONSTRUCTION BECAUSE FORD MOTOR COMPANY PUBLICLY REFERENCES CORPORATE POLICIES AND DIRECTIVES RELATED TO PRODUCT QUALITY, SAFETY AND ENVIRONMENTAL MATTERS APPLYING TO ITS GLOBAL OPERATIONS. AS OF NOVEMBER 2017, NO RECONSTRUCTION REPORT NOR INVESTIGATIVE REPORT NOR FINDINGS WERE PROVIDED TO ME BY EITHER FORD MOTOR COMPANY OR MY LOCAL FORD DEALERSHIP. I PROVIDED NOTICE TO FORD MOTOR COMPANY AND MY LOCAL FORD DEALERSHIP I WOULD CONTACT THE NHTSA REQUESTING AN INVESTIGATION INTO THIS EVENT(S) ASSERTING MY CONSUMER PROTECTED RIGHTS TO INFORMATION, HONEST SERVICES, SAFETY, CHOICE, AND EQUAL PROTECTION HAD BEEN VIOLATED. I REQUEST MY SAFETY COMPLAINT BE RECEIVED AND REVIEWED FOR FURTHER INVESTIGATIVE ACTION.
TL* THE CONTACT OWNS A 2009 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 5 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED AND CRASHED INTO A BRICK WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT MULTIPLE PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
CAR OFTEN FILLS WITH A STRONG SULFUR (EGG LIKE) SMELL. VERY NOTICEABLE AFTER LONG TRIPS OR VERY HOT DAYS. THIS HAS BEEN HAPPENING FOR SEVERAL YEARS.
TL* THE CONTACT OWNS A 2009 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE STALLED AND THE WRENCH WARNING INDICATOR ILLUMINATED. THE CONTACT HAD TO COAST TO THE SHOULDER WITH NO POWER BRAKE OR STEERING ABILITY. THE CONTACT WAITED FOR APPROXIMATELY TWO MINUTES AND STARTED THE VEHICLE NORMALLY, BUT THE WARNING INDICATOR WAS STILL ILLUMINATED. THE DEALER DIAGNOSED THAT THE THROTTLE BODY FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 31,000. ...UPDATED 02/22/17 *BF *TR
Showing 12 of 33 complaints.