Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2010 Ford Explorer, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ford Explorer year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 2 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: FORD IS RECALLING CERTAIN MODEL YEAR 2010 FUSION, EXPLORER, EXPLORER SPORT TRAC, AND MERCURY MILAN AND MOUNTAINEER VEHICLES MANUFACTURED BETWEEN DECEMBER 15, 2009 THROUGH FEBRUARY 3, 2010 EQUIPPED WITH FRONT SEAT MANUAL RECLINERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINT." THE RECLINER GEAR PLATE TEETH MAY BE OUT OF DIMENSION SPECIFICATION WHICH COULD RESULT IN LIMITED PAWL TO GEAR PLATE TOOTH ENGAGEMENT.
Risk: IN THE EVENT OF A CRASH, THE SEATBACK AND HEAD RESTRAINT MAY MOVE REARWARD, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL REPLACE THE MANUAL RECLINERS FOR BOTH POWER AND MANUAL SEATS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 30, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Campaign 10V161000
Issue: MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
Risk: AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
Remedy: MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Campaign 10E043000
NHTSA frontal crash test
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2010 Ford Explorer 4-DR. w/SAB
The parts named most often across 115 owner complaints filed with NHTSA for this make, model and year.
2 crashes · 10 injured · 50 deaths
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
50 complaint-reported fatalities on this model.
Odometer Fraud. The contact purchased a 2010 Ford Explorer. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the mileage was 135,902. The contact stated that while the vehicle was being serviced, it was later discovered that the mileage on the Title was 224,283. The information was from a Carfax Report.
Thing accelerate by itself while on highway od light blinking at high speeds and then when you come to a complete stop and try to takeoff it goes really slow with the RPMs high then it will kick into gear, unsafe on the road. Truck willjump in gear then out on takeoff.
Odometer Fraud. The contact purchased a 2010 Ford Explorer. The contact discovered a mileage discrepancy after purchasing the vehicle. The vehicle was a dealer sale. At the time of purchase, the mileage was approximately 150,000. Most recently, the contact downloaded the Ford App, and when the maintenance history was checked, it was later discovered that the mileage on the Title was approximately 243,000. The contact stated that the date listed on the Ford App was June 2025.
3 times this has happened. I brake and it seems like I'm pressing the gas pedal and the brakes feel like they aren't stopping the vehicle. The third time put me in incoming traffic and the vehicle was totaled as it already had a rebuilt salvage title when we bought it.
The contact owns a 2010 Ford Explorer. The contact stated that while driving approximately 45 MPH, the anti-theft, roll stability, and fuel filler messages were displayed with an audible alarm before the vehicle suddenly shut off. The contact was able to restart the vehicle and drove to the residence. However, the failure reoccurred, and the vehicle was towed to the local mechanic who diagnosed that the PCM and ECM had short circuited and failed. The contact was informed that the short circuit was caused by water drainage from the moonroof onto the PCM and ECM computers. The contact stated that the moonroof had previously failed and failed to properly close. The vehicle was not yet repaired. The local dealer and manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the ECM and PCM computers were no longer available. The failure mileage was 48,000.
Transmission , Wheel Hub
Runs for about 25 minutes then just dies while driving. Starts back after sits for about an hr and does same thing.
Oil leak in both valve gasket covers oil on the crossmember it started slow then it was traced by Ford to the gaskets(fire hazard) 120 k on odometer
The air bag light will not go off. I have checked the the wiring, cleared the area, and checked all fuses. All checked out okay. I'm a new buyer and can't register the car until it passes inspection. My only conclusion is that it possibly has a defect or has been previously been deployed. There is no record of a previous collision as of yet, although that may not be factual as the car has had a drivers door panel replaced. Can you help with the air bag information? Also, Is there a financial aid grant or some help in obtaining/repairing the problem for low or no income families? Thank you for your time in this matter. Sincerely, Kelly F. kewkarooo@gmail.com
The contact owns a 2010 Ford Explorer. The contact stated that while driving approximately 20 mph and attempting to stop, the brake pedal extended to the floorboard causing the driver to lose control of the vehicle and crash into a guard rail. During the crash, no injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The local dealer and manufacturer were not notified of the failure. The failure mileage was 92,600
Rsc alarm keeps going sounding alarm and the abs alarm keeps sounding as well. Seen a ton of owners having this same error
Driving 65 mph on I95 and it just shut off. The yellow wrench on dash came on. I somehow was able to Pull over to the shoulder without being killed. I cranked once then tried it again and it started. Drove all the way home and it’s running fine now. This is a common problem and Ford should be contacting me to warn me and fix it. By the way I had a baby in the car. Thanks Ford for the warning.
Showing 12 of 115 complaints.