Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2015 Ford F-150 Regular CAB — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ford F-150 Regular CAB year.
No EPA fuel-economy match for this model (naming may differ or it predates EPA records).
5 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2015 Ford F-150 Regular Cab PU/RC 4x4
HTTP 400 Bad Request
The parts named most often across 1,425 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
5 crashes · 4 injured
1 crash · 3 fires · 1 injured
1 fire
1 crash · 2 injured
2 crashes · 1 injured
1 crash
2 crashes · 4 injured
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
2 complaint-reported fatalities on this model.
Transmission down shifts while accelerating, slips when starting from a dead stop, and shifts extremely hard when shifting. It is a safety risk especially when pulling out at an intersection, as it stops (or will slip) in the middle of the intersection. It has not been confirmed by the manufacturer or dealer, only by the article from USA Today. The vehicle has not been inspected by anyone, as it just started yesterday. There were no early indications or warning signs prior to it starting yesterday (08/06/2025).
Galvanic corrosion of transfer case.
I have 80,000 and my transmission went out driving up a mountain road No waring light no over heating it just stop going . My shop believes it was from the factory the trans pump went out.I see your looking into this year for trans problem.
The contact owns a 2015 Ford F-150. The contact stated that while driving on the highway at 65 MPH, the transmission downshifted to 1st gear from 6th gear, causing the rear wheels to lock up temporarily, and the check engine warning light illuminated. The contact pulled over and restarted the vehicle; however, while driving, the transmission only shifted from 3rd to 5th gear. The following day, the vehicle continued to drive normally through all the gears as designed. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the transmission was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 115,000.
Transmission slips into third at high rate of speed exceeding 45 mph. Transmission will stay in third causing slow acceleration on turns.
The contact owns a 2015 Ford F-150. The contact stated that while driving at 45 MPH, the gear shifter independently shifted out of the intended position. The check engine warning light was illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed, and determined that the transmission range sensor needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 24V444000 (POWER TRAIN); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 112,000.
The contact owns a 2015 Ford F-150. The contact stated that while driving 75 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the check engine warning light illuminated, and the vehicle stalled. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The dealer was made aware of the failure; however, the contact was requested to pay a diagnostic fee. The contact stated that due to the persistent failure, the contact was fearful of driving the vehicle. The contact stated that the failure had occurred four times. The manufacturer was made aware of the failure, and a case was filed. The contact referenced an unknown recall; however, the VIN was not included in the recall. The contact was advised to contact the NNHTSA Hotline to report the failure. The failure mileage was approximately 80,000.
For the past 3 days, I have had intermittent loss of steering from a power steering failure while driving on interstates/highways. Almost completely unable to steer it to safety on the side of the road. Ford has a recall(15S18), but I was told its vin-specific. My truck's vin does not fall under the recall, yet im having the same problems as the recall claims. Reaching out to see if this can be resolved and have a recall initiated. Thank you
i was driving my truck down the highway and all of a sudden my rears wheels locked up making me lose control of my truck take goodness i did'nt rollover no my transmission is shifting threw gears from 1st to 6th to 3rd this is my second f150 that i have had my old one had the same problem but my old one didnt lock up my tires my phone number is [XXX] [XXX] but please text because at work you cant use my phone my truck is parked in the garage im afraid to drive it need assistance in fixing it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Began experiencing hard shifting unexpectedly. Took it into dealership and they advised my lead frame assembly needed replacement. In research, I found this is currently under investigation by the NHTSA's office for my year and transmission model.
First time this incident happened (around April 2025) while driving on the highway. Going about 70 mph and the truck dropped down into second or first gear almost causing an accident. Had to pull over on the side of the road. Check engine light was on the dash. Turned off the truck And let it sit a little bit and restarted it and it seemed to be OK. This most recent incident happened on Saturday, July 5th 2025 , truck kept dropping down into first gear and then just would not go anywhere. Had it towed to Auto clinic and they diagnosed the truck with not recognizing the gear selection position. They stated that this truck should have fell under the recall status for 2015-2017 f150’s as it is doing the exact same thing that they have seen many trucks get fixed for because of the recall. The Auto clinic recommended I file a safety report and also contact Ford.
The engine while operating at normal speed loses power to a rough idle and is remedied by putting the vehicle in park and restarting the engine. The engine never fails to start after restarting, but could fail at any moment, short or long term.
Showing 12 of 1,425 complaints.