Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2019 Mini Cooper S — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Mini Cooper S year.
NHTSA lists 1 recall for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: BMW of North America, LLC (BMW) is recalling certain 2018 BMW 540d xDrive vehicles. The crankshaft sensor may be equipped with incorrect firmware, preventing the sensor from properly processing input from the crankshaft reluctor ring, possibly resulting in a vehicle stall. On September 12, 2018, BMW expanded the recall to a total of 5,309 vehicles including certain 2018-2019 BMW 540d xDrive, 230i M240i, M240i xDrive, X2 sDrive28i, X2 xDrive28i, X1 sDrive28i, X1 xDrive28i, 330i, 330i xDrive, 340i, 340i xDrive, 330i xDrive Gran Turismo, 530i, 530i xDrive, 540i, 540i xDrive, 530e, 530e xDrive, 640i xDrive Gran Turismo, 330e, 2019 430i Gran Coupe, 430i xDrive Gran Coupe, 440i Gran Coupe, 440i xDrive Gran Coupe, 430i, 430i xDrive, 440i, 440i xDrive, 740i, 740i xDrive, MINI Cooper, Cooper S, JCW, MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), and MINI Clubman (Cooper, Cooper S, Cooper All4, Cooper S All4, JCW All4) vehicles.
Risk: A vehicle stall can increase the risk of a crash.
Remedy: BMW will notify owners, and dealers will replace the crankshaft sensor, free of charge. The recall began September 6, 2018. Owners may contact BMW customer service at 1-800-525-7417.
Campaign 18V465000
No EPA fuel-economy match for this model (naming may differ or it predates EPA records).
NHTSA has no NCAP crash-test rating for this model/year (common for older, low-volume, or heavy-duty vehicles).
The parts named most often across 4 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
The contact owns a 2019 Mini Cooper S. The contact stated that while driving at an undisclosed speed, the contact noticed that a rock had hit the driver's side of the windshield due to construction work on a local highway. The contact stated that the passenger's side of the windshield was also hit by a rock while driving. The contact stated that the driver's side of the windshield sustained a minor fracture; however, the passenger's side of the windshield was severely damaged. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 81,485. The VIN was not available.
Loss of power steering on startup or at stop light. A message pops up indicating that the Dynamic Stability Control is re-initializing and that steering may become difficult: Drive carefully. The warning message usually appears shortly after the failure. In fact, the steering gets so stiff, that my wife can barely turn corners. The problem comes and goes unexpectedly. This is my wife's car, and it has happened to her on several other occasions. Sometimes we can reset by restarting the car, but that isn't reliable. We put the car out of ECO mode into Sport mode, so that the engine does not stop at stop lights, but the engine sometimes stops anyway. When it happened at a stop light today, we tried several restarts, but the steering remained out. Steering is worse at low speeds. Today, we stopped at a light. My wife was driving. The engine stopped and restarted, and the error message appeared. She had difficulty steering into a parking lot where I swapped places with her. I drove her home. It was difficult for me to steer around corners after today's lock up, but I drove the car to a local BMW-Mini mechanic with whom I had discussed the problem, but it never appeared at his shop. Today, we tried starting at the shop and the difficult steering persisted without an error message. He ran a quick scan indicating that some modules in the steering column were not operating properly. He said the modules were not available for replacement, and that the entire steering column might need to be replaced. Unfortunately, he was booked up until Friday. I drove home and let the car sit in the garage for a couple of hours. I started it while writing this to try to more accurately reproduce the warning messages. However, no messages appeared and the car steered easily. Clearly, sudden loss of power steering poses a danger for my family and others on the road. I've looked on the internet and discovered that others have experienced similar problems with steering in Mini Coopers.
The contact's daughter owns a 2019 Mini Cooper S Clubman. The contact stated that while his daughter was driving at an undisclosed speed, she depressed the brake pedal, but the rear driver's side brake light failed to illuminate. The contact stated that he was driving behind his daughter when he noticed the failure. The vehicle was taken to an independent mechanic, and the rear driver's side brake light bulb was replaced; however, the failure persisted. The mechanic referred the contact to the dealer for assistance. Additionally, the contact stated that the vehicle failed to start. The vehicle was jumpstarted by AAA. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that they could not assist unless NHTSA required that they do so. The failure mileage was unknown.
175 MILES ON 2019 MINI S COUNTRYMAN. TRAVELING AT HIGHWAY SPEED. DRIVETRAIN MALFUNCTION INDICATOR CAME ON, CAR SHUDDERED REPEATEDLY AND DECELERATED RAPIDLY TO APPROX. 20 MPH IN 60 ZONE. CREATED INSTANT HAZARD TO MYSELF AS MULTIPLE LANES OF FASTER MOVING TRAFFIC NEEDED TO BE CROSSED TO REACH SAFETY AND NO WARNING TO TAILING VEHICLE.