Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2002 Mini Cooper — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Mini Cooper year.
29.7 mpg average · 22–39 range · EPA says 25
Over 5 years this costs $4,250 more in fuel than an average new vehicle.
NHTSA lists 5 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Risk: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
Campaign 15V660000
Issue: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000
Issue: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000
Issue: ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE TRANSMISSION SHIFT CABLE CONNECTS THE GEARSHIFT LEVER IN THE VEHICLE INTERIOR TO THE SHIFT LINKAGE ON THE TRANSMISSION. IT IS POSSIBLE FOR THE SHIFT CABLE TO DETACH FROM THE TRANSMISSION SHIFT LINKAGE WHILE THE DRIVER IS ATTEMPTING TO CHANGE GEARS. IF THE CABLE DETACHES FROM THE SHIFT LINKAGE, GEAR CHANGES WILL NO LONGER BE POSSIBLE AND THE TRANSMISSION WILL REMAIN IN THE LAST GEAR SELECTED.
Risk: IF SHIFT CABLE DETACHMENT OCCURS AND THE TRANSMISSION REMAINS IN ANY FORWARD GEAR, THE VEHICLE CAN STILL BE DRIVEN IN THAT GEAR ONLY. HOWEVER, IF THE TRANSMISSION MOVES INTO NEUTRAL AND REMAINS THERE, THE ABILITY TO ACCELERATE OR MAINTAIN SPEED WILL BE LOST, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE SHIFT CABLE AND, IF NECESSARY, INSTALL A RETAINING CLIP OVER THE END OF THE SHIFT CABLE TO PREVENT IT FROM DETACHING FROM THE TRANSMISSION. OWNER NOTIFICATION BEGAN AUGUST 6, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BMW AT 1-866-ASK-MINI (1-866-275-6464).
Campaign 02V201000
Issue: CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE STANDARD REQUIRES THAT THE RELATIONSHIP BETWEEN THE TIRE SIZE AND MAXIMUM TIRE PRESSURE BE INDICATED ON THE VEHICLE'S TIRE INFORMATION LABEL. THIS RELATIONSHIP IS NOT PRESENT.
Risk: TOO LOW OR TOO HIGH TIRE PRESSURE CAN CAUSE PREMATURE WEAR AND/OR TIRE DAMAGE, AND COULD LEAD TO UNFAVORABLE DRIVING CONDITIONS.
Remedy: OWNERS WILL BE PROVIDED WITH NEW TIRE INFORMATION PLACARDS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON NOVEMBER 30, 2005. OWNERS MAY CONTACT MINI AT 1-866-275-6464.
Campaign 05V470000
NHTSA frontal crash test
5 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2002 MINI Cooper w/SAB
The parts named most often across 269 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
1 crash · 3 fires
1 crash · 2 injured
1 crash · 1 fire · 3 injured
1 crash · 2 fires
2 fires
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer gauge cluster. This would happen everytime. Wires are intact with no signs of damages to all 3 wire connectors under the seat.
Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't have any issues.
The contact owns a 2002 Mini Cooper S. The contact stated that while driving approximately 45-55 MPH, the steering wheel seized. There was no warning light illuminated. The vehicle was coasted to the side of the road. The contact restarted the vehicle and continued driving normally. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 15V660000 (STEERING). The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 43,000.
Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It was night, I was sitting in middle of my lane, unable to start Mini. Good samaritans helped push it into parking lot while waiting for assistance. After 15 minutes, car started and was driven home. I had slight injuries from being hit by hard material projectiled across cabin. Very thankful I was the only occupant because if a passenger had been in the seat, they would have most definitely sustained injuries. I had to cut the airbags out in order to have clear lines of sight before driving the following day. I’m fearful that the drivers side air bags may do this as well. I have owned this vehicle since 2004. Not aware of history prior to 2004;(accidents, original airbags?). only know it came from a Dealer in CA. (Possibly “Friendship” may be name of town or dealership). I have not had repairs made yet. I don’t drive this vehicle daily. There are no police reports since there was no need. No insurance claims since 2002 model. There were no malfunctions with the warning light prior to incident. However, the following day when I drove, the airbag indicator light came on for passenger side. I did not find a recall but not sure if I would for a 22 year old vehicle.
MY MINI COOPER NEEDS RECALL WORK DONE. I AM IN BILLINGS, MT AND 392 MILES FROM THE CLOSEST CERTIFIED PLACE TO GET IT REPAIRED. I CAN'T TRAVEL THAT FAR IN A 2002 VEHICLE WITH HIGH MILES DURING A PANDEMIC. I AM A SENIOR CITIZEN AND HAVE ISSUES THAT DO NOT ALLOW ME TO TRAVEL THAT FAR. I AM STUCK WITH A VEHICLE THAT MAY HAVE A POTENTIAL STEERING ISSUE WITH NO WAY TO RESOLVE IT. I NOW CAN'T SELL THIS VEHICLE EITHER BECAUSE IT WOULD BE MORALLY WRONG TO PASS THIS PROBLEM ON TO A NEW OWNER. I CAN'T AFFORD THIS KIND OF SAFETY AND FINANCIAL PROBLEM. I NEED HELP TO GET THIS WORK DONE AND MINI COOPER CALLED ME AFTER MY INQUIRY AND SAID I AM BASICALLY OUT OF LUCK. THEY HAVE NO RESOLUTION FOR ME OR ANY OTHER MINI COOPER OWNERS THAT LIVE IN RURAL STATES AND ARE NOT NEAR A CERTIFIED DEALERSHIP. I NEED THIS REPAIRED AND AM HOPING YOU CAN HELP ME AND ALL THE OTHER MINI COOPER OWNERS IN THIS DANGEROUS SITUATION. THE NUMBER THE MINI REPRESENTATIVE CALLED ME FROM WAS 800-831-1117.
SO I BOUGHT A 2002 MINI COOPER LESS THAN A YEAR AGO AND IT CURRENTLY HAS 74K MILES AND ATTEMPTING TO PULL INTO A PARKING SPOT AT THE GROCERY MY STEERING GOES COMPLETELY OUT WHILE I WAS TRYING TO TURN INTO MY SPOT AND RIPPED OFF A BLACK MOLDING THAT GOES OVER THE FRONT PASSENGER WHEEL AND A SIGNIFICANT DING AND SCRATCH.
THE VIN # OF MY 2002 MINI COOPER S WAS NOT INCLUDED IN THE RECALL FOR THE ELECTROHYDRAULIC STEERING FAILURE OF 2002 - 2005 MINI COOPER S BUT I AM EXPERIENCING THE EXACT ISSUE OUTLINED IN THIS RECALL. THE STEERING IS INCREDIBLY HARD TO TURN WHEN PARKED, AS WELL AS WHILE DRIVING. I NOTICED THAT THE RECALL HAD ABOUT 339 COMPLAINTS AND ROUGHLY 85,000 VEHICLES WERE RECALLED, SO MAYBE AT THE TIME NO ONE WITH A SIMILAR VIN AS ME COMPLAINED.
PURCHASED THIS CAR USED WITH LOW MILES. SHORTLY AFTER PURCHASE I NOTICED THE STEERING ON MY VEHICLE GOT A LITTLE HARDER TO STEER, DIDN'T THINK TO MUCH ABOUT IT. THEN THE RADIATOR FAN WOULD NOT TURN OFF WHEN THE VEHICLE WAS OFF. TOOK THE CAR IN TO TWO DIFFERENT MECHANICS TO FIND THE PROBLEM. FOUND OUT IT WAS THE POWER STEERING PUMP WENT OUT CAUSING THE COOLANT RESERVOIR TO GO OUT. THIS COULD CAUSE EXTREME SAFETY HAZARDS WHEN DRIVING ON THE FREEWAY AND THE STEERING FREEZES!! I CONTACTED BMW AFTER HEARING THERE WAS A RECALL FOR THIS SAME PROBLEM. I WAS TOLD WE MISSED THE RECALL TIME FRAME. I HAVE LOW MILES, 60,000. THE RECALL EXPIRED IN 2017. WELL, MY CARE WAS NOT HAVING THE ISSUES. I DON'T FEEL COMFORTABLE SELLING THE CAR AND HANDING THE PROBLEM TO ANOTHER CONSUMER. THIS RECALL SHOULD BE EXTENDED AS IT COULD BE AN UNPLEASANT RESULT.
TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. THE CONTACT, A CERTIFIED MECHANIC, DIAGNOSED THAT THE STEERING PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
POWER STEERING SUDDENLY STOPPED WORKING. MAKING A WHINING NOISE WHEN TURNING THE WHEEL AND THE STEERING WHEEL ITSELF IS HARD TO TURN. NOT LEAKING ANY FLUIDS AND THE POWER STEERING FLUID IN THE RESERVOIR IS FULL.
TL* THE CONTACT OWNS A 2002 MINI COOPER S. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS CONTACTED AT 865-693-4553 AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WATER WAS ENTERING THE VEHICLE FROM THE SUN ROOF, WHICH CAUSED THE COMPUTER IN THE VEHICLE TO GET MOIST AND NOT OPERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF RUBBER CONNECTOR NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.
Showing 12 of 269 complaints.