Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2004 Mini Cooper — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Mini Cooper year.
Over 5 years this costs $4,250 more in fuel than an average new vehicle.
NHTSA lists 4 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: BMW of North America, LLC (BMW) is recalling certain model year 2002-2005 MINI Cooper and Cooper S vehicles and 2005 Cooper and Cooper S Convertible vehicles. The affected vehicles may experience temporary or permanent loss of the electro-hydraulic steering assistance.
Risk: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, potentially increasing the risk of a vehicle crash.
Remedy: MINI will notify owners, and dealers will inspect the electro-hydraulic power steering system, replacing the components and wiring, as necessary, free of charge. Interim notices were mailed to owners on December 10, 2015. Owners will receive a second notice when remedy parts become available. Owners may contact MINI customer service at 1-866-825-1525.
Campaign 15V660000
Issue: K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: K2 MOTOR WILL NOTIFY OWNERS AND OFFER A FULL REFUND. THE RECALL BEGAN ON DECEMEBER 17, 2008. OWNERS MAY CONTACT K2 MOTOR AT 1-909-839-2992.
Campaign 08E050000
Issue: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000
Issue: ON CERTAIN PASSENGER VEHICLES, THE FLAT TIRE MONITORING SYSTEM HAS NOT BEEN CORRECTLY PROGRAMMED. IN THE EVENT OF A FLAT TIRE, AN AUDIBLE SIGNAL WILL NOT SOUND TO ALERT THE DRIVER TO A FLAT TIRE.
Risk: DUE TO THE LACK OF AN AUDIBLE SIGNAL, THE DRIVER MAY NOT BE AWARE OF A FLAT TIRE, WHICH COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPROGRAM THE VEHICLE'S SOFTWARE IN ORDER TO ACTUATE THE FLAT TIRE MONITORING SYSTEM'S AUDIBLE SIGNAL. THE RECALL BEGAN OCTOBER 13, 2004. OWNERS SHOULD CONTACT MINI CUSTOMER RELATIONS AT 1-866-275-6464.
Campaign 04V348000
NHTSA frontal crash test
2 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2004 MINI Cooper w/SAB
The parts named most often across 529 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
10 crashes · 3 fires · 2 injured
4 fires
1 fire
1 fire · 1 injured
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
1 complaint-reported fatality on this model.
The contact owns a 2004 Mini Cooper. The contact received notification of NHTSA Campaign Number: 15V660000(STEERING); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had experienced the failure, causing the driver to lose control of the steering and drive off the road. The exact cause of the failure was not determined, and the vehicle was not repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 160.000. Parts distribution disconnect.
Mini felt like it was getting pushed by the wind . Realized wasn't wind Mini loss of completely all functions of steering wheel. On super busy highway. Devine intervention Was in far left car went left to right lanes then hit median gaurd rail spun around Finally got it to stop. Never Hitting and hurting anyone around me. Nobody hit me. Car is totalled ! Still at tow place. I saw my life flash as cars were zooming by me. Someone should be held responsible for my car and almost my life. Called out of work can't move upper body that well.
WAS DRIVING CAR ON 18 JULY 2020 AND POWER STEERING QUIT WORKING AND MADE STEERING DIFFICULT, ALSO COOLANT FAN,LOW SPEED AND HIGH SPEED STOPPED WORKING SAME TIME AS POWER STEERING QUIT. THE ASC LIGHT CAME ON AND IT WILL NOT TURN OFF. NO BLOWN FUSES IN ENGINE COMPARTMENT OR BY DRIVERS KICK PANEL. I WAS DRIVING THE CAR ON A STATE ROAD WHEN THIS OCCURRED.
TL* THE CONTACT OWNS A 2004 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT ATTEMPTING TO MAKE A TURN, THERE WAS AN ABNORMAL GRINDING SOUND COMING FROM THE STEERING COLUMN. THE CONTACT ALSO STATED THAT THERE WAS A POWER STEERING FLUID LEAK PRESENT. THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO MINI OF STEVENS CREEK LOCATED AT (4201 STEVENS CREEK BLVD, SANTA CLARA, CA 95051), AND DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 156,000.
THE POWER STEERING IS VERY STIFF TO DRIVE AND CANNOT DRIVE MY COOPER BECAUSE I CAN NO LONGER STEER THE VEHICLE.
WHEN YOU TURN WHEEL LEFT OR RIGHT IT MAKES A NOISE AND IT'S VERY HARD TO TURN. SO I THINK IT'S THE STEERING: ELECTRIC POWER ASSIST SYSTEM. RECALL ID # 240625.
MY WIFE WAS DRIVING OUR 2004 MINI COOPER HOME TRAVELING UPHILL ON A STEEP PAVED MOUNTAIN ROADWAY TRAVELING A MAXIMUM OF 15 MPH WHEN FOR SOME UNKNOWN REASON THE VEHICLE LEFT THE ROADWAY; STRUCK A TREE WITH ITS LEFT FRONT AND BURST INTO AN EXPLODING FIRE KILLING MY WIFE WHO WAS NOT ABLE TO ESCAPE THE BURNING VEHICLE. THE NC STATE POLICE ARE INVESTIGATING THE CAUSE OF THE FIRE AND DEATH. THEY DO NOT KNOW YET WHETHER THE VEHICLE CAUGHT FIRE PRIOR TO STRIKING THE TREE BUT, FEEL THE FIRE COULD NOT HAVE BEEN CAUSED BY THE VEHICLE STRIKING THE TREE AT A LOW IMPACT AND SPEED. NC MV ACCIDENT REPORT#[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
ALL MODELS FROM 2005 ONWARD HAVE BEEN RECALLED, YET EARLIER MODELS HAVE THE SAME PROBLEMS WITH NON FUNCTIONING AIRBAGS. THE AIRBAG WARNING LIGHT IS ON CONTINUALLY, AND THERE ARE KNOWN PROBLEMS WITH WIRING, PRESSURE MATS AND CONNECTORS IN THESE VEHICLES. BMW IS INTENTIONALLY IGNORING THESE ISSUE. MY OWN PERSONAL VEHICLE HAS THIS PROBLEM AND AS A GOVERNMENT MANDATED SAFETY DEVICE I BELIEVE THAT EARLIER MODELS OF MINI COOPERS SHOULD BE INCLUDED IN THE RECALL!
MAINLY WHILE COLD AND AT LOW SPEED'S THE WHEEL SUDDENLY BECOMES VERY HARD TO TURN AND I WAS TOLD BY A MECHANIC BUT IT'S A FAULTY HYDRAULIC POWER STEERING PROBLEM
VERY HARD TO TURN STEERING WHEEL AT TIMES ESPECIALLY WHEN MOVING SLOWLY; COMING TO A TURN AT A LIGHT, BACKING OUT OF A PARKING SPOT, ETC.
2004 MINI COOPER PURCHASED NEW APROX 62 MILES ON IT AND THE CVT TRANSMISSION IS GONE & THERE WAS A CLASS ACTION LAWSUIT FOR THE REPLACEMENT OF THIS, I WAS NEVER NOTIFIED AND WANT THIS FIXED AT NO COST TO ME. AT APROX. 50 TO 60 MPH THE CAR ENGINES GOES WAY BEYOND THE PROPER RPM.
TL* THE CONTACT OWNS A 2004 MINI COOPER. THE CONTACT STATED THAT THE STEERING WHEEL WAS DIFFICULT TO TURN IN EITHER DIRECTION. THE ELECTRIC POWER STEERING WARNING INDICATOR WAS NOT ILLUMINATED. AN UNKNOWN DEALER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY, AND WAS EXCLUDED FROM NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) AND NHTSA ACTION NUMBERS: EA11005 (STEERING) AND PE10038 (STEERING). THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.
Showing 12 of 529 complaints.