Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2022 Ram 5500 — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ram 5500 year.
No EPA fuel-economy match for this model (naming may differ or it predates EPA records).
NHTSA warns this vehicle can catch fire while parked and switched off (2 recalls). Park outside and away from structures until it is repaired.
Recalls are issued per model. Confirm whether this specific car has already been repaired using its VIN — free, at any franchised dealer or on nhtsa.gov/recalls.
NHTSA lists 4 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 3500, 2500 pickup trucks, and Ram 3500, 4500, and 5500 cab chassis vehicles equipped with Cummins 6.7L Turbo Diesel engines. An electrical short in the relay may cause a vehicle fire with the ignition on or off.
Risk: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park these vehicles outside of buildings or structures, and not near other vehicles, until the vehicle has been remedied. Dealers will inspect and, if needed, replace the Solid State Intake Heater Grid Relay ("Relay"); if FCA US Recall ID Y08 (NHTSA Recall ID 21V-163) is open, then insulating material will be applied to the Relay after inspection. Owner notification letters were mailed November 10, 2021. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Y76. This recall has been superseded by 23V060.
Campaign 21V798000
Issue: Chrysler (FCA US, LLC) is recalling certain 2021-2023 Ram 2500, 3500, 3500 Cab Chassis, and 4500, 5500 Cab Chassis vehicles equipped with a Cummins 6.7L Turbo Diesel engine. An electrical short may occur in the heater grid relay with the ignition on or off.
Risk: An electrical short in the relay can result in an engine compartment fire with the ignition on or off, increasing the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the relay, free of charge. This will be a Phased campaign. Phase 1 will include 2023 model year vehicles. FCA US will notify dealers on or about 3/23/2023 and begin notifying owners on or about 4/5/2023. Phase 2 will include 2022 model year vehicles and Phase 3 will include 2021 model year vehicles. FCA US will notify dealers and owners on or about 4/27/2023 for Phase 2 and 5/11/2023 for Phase 3. Interim owner notification letters informing owners of the safety risk were mailed March 28, 2023. Owner notification letters are expected to be mailed April 5, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 13A. This recall is an expansion of and supersedes recall number 21V-798.
Campaign 23V060000
Issue: Chrysler (FCA US, LLC) is recalling certain 2022 Ram 3500, 3500 Cab Chassis, Ram 2500, and 4500 and 5500 Cab Chassis vehicles equipped with Cummins 6.7L turbo diesel engines. The engine control module (ECM) may have been built with a misaligned capacitor that can short-circuit, resulting in an internal loss of communication.
Risk: An internal loss of communication can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will replace the ECM, free of charge. Owner notification letters were mailed October 20, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is Z87.
Campaign 22V642000
Issue: Chrysler (FCA US, LLC) is recalling certain 2021-2022 Ram 1500, Ram 2500, Ram 3500, Ram 4500, and Ram 5500 vehicles. The steering column control module may cause the driver's side air bag not to deploy as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk: A driver's side air bag that does not deploy as intended increases the risk of injury in a crash.
Remedy: Dealers will replace the steering column control module, free of charge. Owner notification letters were mailed beginning December 11, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 14C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning November 13, 2025.
Campaign 25V765000
NHTSA has no NCAP crash-test rating for this model/year (common for older, low-volume, or heavy-duty vehicles).
The parts named most often across 26 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
1 crash
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
Our driver told us that he lost steering. At 35 mph on a open highway (which is confirmed by our gps). He also has a clean driving record and has been driving box truck for decades with no incident. Once steering was lost the box truck to slam in into the barrier twice , than roll onto its side. There where no other cars involved in the accident and the truck is now totaled. There is so much damage done to the truck it is hard to pinpoint the failure point. The center link is broken and the tie rod end is snapped off. The truck only has 38,000 miles on it. The air bags weren't deployed and the driver had to be pulled out of the truck. The police confirmed the steering failure point on the police report. There was no warning of the failure. Until the accident.
Dealership confirmed K1 and K2 snap ring failure on a 22 Dodge Ram under warranty with 15933 miles. Transmission was manufactured in August of the truck build. On [XXX] while driving my 22 Ram 5500 the truck lost all forward gears while coming down the mountain with a loaded truck camper and pulling a trailer with an ATV. Truck was below GVWR. This truck had 15933 miles and 24 months old. All servicing intervals were met and serviced at a certified Dodge dealership. The truck was traveling at 25 MPH down hill in steep terrain on a dirt road. The exhaust brake and tow haul mode was selected and operational. The vehicle shuddered and made a thump and had an associated check engine light with an Adaptive Cruise Control caution indication. The vehicle started to rapidly speed up downhill and I gently applied the brakes to regain control. I coasted approximately 2 miles to find a safe pull off point in the mountains with no forward gears. After the vehicle was safely stopped I was able to confirm the malfunction with no forward gears and reverse only. I was fortunate to be able to flag a ride after hiking out to the [XXX] to get my wife and I out of the National Forest and get cellular service. The nearest service provider was the Ram dealership in Lewiston Idaho. I made arrangements and the Truck was delivered the next day by a semi tow vehicle. We incurred a two night stay at the Hampton Inn to get repairs lined up and arrange travel home. After multiple conversations with the dealership and a trip down there to discuss the issue with the dealership they finally diagnosed and fixed the problem after 33 days sitting on the lot. The truck was delivered back to me on 9 October. The diagnosis of the K1 and K2 snap ring poses a serious safety issue for owners and operators of this vehicle. This malfunction caused some significant financial burden as well due to the truck being inoperative and away 140 miles from home. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2022 Ram 5500. The contact stated while driving at approximately 40 MPH, the vehicle was losing forward momentum. The contact stated that the check engine warning light was illuminated. The contact depressed the accelerator pedal and the engine was revving but the vehicle was not gaining any forward momentum. The contact pulled the vehicle over and turned the vehicle off and on, however, when the contact had shifted the vehicle into drive (D) the vehicle was not moving. The contact determined that he only had reverse (R) gear functioning. The contact had checked online and read that he would be able to manually shift to 5th gear. The contact was able to return to his workplace and had the vehicle towed to a local dealer. The vehicle was diagnosed and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The contact had researched online and related the failure to NHTSA Action Number: PE24009 (Power Train). The manufacturer was not informed of the failure. The failure mileage was approximately 105,000.
The contact owns a 2022 Ram 5500. The contact stated while driving 50–55 MPH, the vehicle lost motive power due to the transmission failure. There were no warning lights illuminated. The vehicle was towed to the local dealer but was not diagnosed or repaired. The vehicle was towed to another local dealer, Speck Chrysler Jeep Dodge Ram (125 E Allen Rd., Sunnyside, WA 98944), where it was diagnosed that the snap ring was fractured. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the local dealer for assistance. The failure mileage was approximately 8,000.
The transmission failed at approximately 3000 miles. Reverse was the only gear to function properly. The truck has been at the dealership for over 2 months and they have not fixed it yet.
K1 snap ring failure
This is a 2022 Dodge Ram 5500. The wheel studs broke off while driving on the interstate, and the dually tires came off. This is a major safety issue and the driver had a narrow escape. This same issue persisted through the 2012-2021 model years and RAM had a recall (Y26) for those years. I do not believe the issue has been fixed for the 2022 model year. When I asked RAM for reimbursement for the replacement studs and labor, they turned it down saying my model year was not on the list I am looking to escalate this matter before someone else gets impacted by this issue.
Truck has 6500 miles, went to put it in reverse from drive in busy intersection and transmission started to slip. Truck ultimately wouldn't drive at all. Started throwing codes (P0731-00 in particular) and found out that it needs a new K1 clutch snap ring repair. There are more than 300 people with this issue, this has not only happened with me from my research on forums about this code being thrown. This is a 2022 with 6500 miles, there are too low of miles on this truck for it to be having a problem like this!
The contact owns a 2022 Ram 5500. The contact stated while driving at an undisclosed speed, the vehicle failed to shift into the intended gear, and started to coast while the accelerator pedal was depressed. No warning light was illuminated. The contact stated that he veered off the roadway to safety and notified a towing company. The vehicle was towed to the dealer where it was diagnosed that the snap rings failed and needed to be replaced. The contact stated that he had previously informed the dealers of TSB: 21-002-23 but was informed that the vehicle needed to experience a complete failure to receive the repair under the TSB. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 1,000.
The contact owns a 2022 Ram 5500. The contact stated while driving 50 MPH, the vehicle lost motive power, with the 4-WD unavailable message displayed. Additionally, the check engine warning light was illuminated. The vehicle was towed to the dealer and the contact was informed that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was contacted, and a case was filed. The failure mileage was 1,973.
I drive a RAM 5500, 20' Jerrdan Flatbed Tow truck. We had just purchased this truck about a week and a half prior to the transmission failure. We had 2500 miles on it, and were towing two vehicles behind. We pulled off of the highway, and then felt an extremely hard clunk underneath the truck to which the rear tires locked up, and stopped us in the middle of the road. Once we were stopped, the truck began to clunk louder so hard it would shake the entire truck. Then a CEL appeared, for PO731 and P0734, the truck in drive would only rev and not move. Reverse did work however. But we could not reverse anywhere as we were in the middle of the highway. We had to get a tow truck which took 4 hours because nobody wanted to tow us due to the situation. We almost got hit so many times, it was so dangerous and scary for me and my passenger, as we thought we were going to crash when the rear wheels locked up. This issue needs to be taken much more seriously and looked into becoming a recall. Somebody on the highway could get KILLED!
Were were driving in stop and go traffic outside Durham, NC on I 147/885. After being stopped for a few seconds I depressed the accelerator to move forward. There was a bang and I thought some one had hit me from behind. Then I noticed the engine light on the dash and the truck would not move forward. I was able to get the shifter in park. All temps and pressures on the dash were normal including the transmission. There was no fluid leaking from under the truck. We were in lane three of the highway and cars, trucks, and tractor trailers were passing us on the shoulder and the left lane. I tried using the in vehicle SOS button but the guy on the other end only referred me to call a different number. That number I sat on the line for over 20min while sitting in traffic unable to move with vehicles passing me on the left and right. finally a deputy showed up and was able to control the traffic. 3 hours later it was finally towed to Hendrick Dodge in Cary, NC. Currently waiting on it to be evaluated by the dealer.
Showing 12 of 26 complaints.