Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2015 BMW 640I — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every BMW 640I year.
NHTSA lists 1 recall for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: BMW of North America, LLC (BMW) is recalling certain 2015 6 Series Gran Coupe, 2014 5 Series Gran Turismo, 2014 5 Series Sedan, 2015 6 Series Convertible, 2015 6 Series Coupe, 2014 X5, 2013-2014 X3, 2014-2015 3 Series Sedan, 2014 4 Series Coupe, 2014 4 Series Convertible, 2014 3 Series Gran Turismo, and 2015 4 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, increasing the risk of injury or death.
Remedy: The driver's front air bag will be replaced, free of charge. Owner notification letters were mailed September 6, 2024. Owners may contact BMW customer service at 1-800-525-7417.
Campaign 24V527000
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2015 BMW 640I 4 DR RWD
No EPA fuel-economy match for this model (naming may differ or it predates EPA records).
The parts named most often across 4 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
1 crash · 2 injured
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
The car is leaking from the third rear brake light (at the rear roof of the car). It appears the seals and possible clips/fasteners have failed and water is entering the car during rain or water immersion from the rear brake light, to the back seat, trunk, and rear floor. There is now visible mold in the car.
THE REAR TIRE WAS LEAKING CAUSING AN UNSAFE ROAD CONDITION. WHEN THE TIRE WAS INSPECTED IT WAS FOUND THAT THE WHEEL HAD A CRACK IN THE SUPPORT DUE TO A DEFECT IN DESIGN. THE DEALER STATES THAT MANY OF THE 5 AND 6 SERIES WITH THIS WHEEL HAVE ISSUES AND OFFERED ME A "WARRANTY PACKAGE" FOR THEM FOR $1700. WHEN DOING RESEARCH ONLINE THIS IS A COMMON PROBLEM AND A CLEAR SAFETY ISSUE. WHEN USED WITH RUN-FLATS (WHAT THEY SUGGEST AND REQUIRE) THE WHEEL TAKES TOO MUCH STRESS AND ULTIMATELY CRACKS. MY VEHICLE HAS LESS THAN 25,000 MILES ON IT AND IT HAS A CRACKED WHEEL WITH NO REASON. THIS IS A CLEAR SAFETY CONCERN AS A RAPID LOSS OF AIR IN A WHEEL MAY CAUSE LOSS OF CONTROL. IT HAS CLEAR CONCERNS FOR STOPPING DISTANCE AND AVOIDANCE AS WELL.
THE TIRES BLEW OUT WHILE ON A ROAD TRIP AT APP 11,000 MILES, SEPARATION RIGHT UNDER THE RIM. TIRES ARE STILL UNDER WARRANTY. HOWEVER, GOODYEAR DUNLOP WON'T BE SQUARE WITH WARRANTY, MAKING THE WARRANTY OF NO VALUE. IN FACT THEY LIED ABOUT THE CAUSE AT FIRST. STILL HAVE THE TIRE FOR REVIEW.
DRIVERS SIDE DOOR OPEN ON ITS OWN, WILL NOT STAY SHUT , DEALSHIP HAS BEEN UNABLE TOO FIX IT? SIDE DOOR DOESN'T CLOSE REPAIRED FOUR TIMES . ENGINE LIGHT COME ON? ROOF LATCH NO AIR BAGS WENT OF?DEALSHIP SAYS CODES SAY?THEY DID?