Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2011 Chevrolet HHR, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Chevrolet HHR year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 3 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Risk: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Campaign 14V171000
Issue: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Risk: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Issue: UCI-FRAM Group is recalling certain LS1328 ignition Switches sold as Wells LS1328, Duralast LS1328, Airtex 1S6097, and Carquest 53-27479, and LS1497 Ignition Switches sold as Wells LS1497, Duralast LS1497, Airtex 1S10961, and Carquest 53-27967, for use on various General Motors model and model year vehicles during repair and replacement of the original ignition switch. The weight on the key ring and/or road conditions or some other jarring event may cause the affected ignition switches to move out of the run position, turning off the engine and disabling the air bags.
Risk: If the ignition switch moves from the run position to accessory, the car would stall and the air bags will not deploy in the event of a crash, increasing the risk of personal injury to the occupants.
Remedy: UCI-FRAM Group has notified its purchasers to quarantine and return all inventory. Any switches already installed in vehicles will be replaced by GM dealers as part of NHTSA recall 14V-047, free of charge. UCI-Fram's purchasers should contact UCI-FRAM Group at 1-800-890-2075. GM vehicle owners requiring additional information on that recall campaign should contact GM at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac) or 1-800-553-6000 (Saturn).
Campaign 14E021000
Campaign 14V047000
Rated configuration: 2011 Chevrolet HHR SUV FWD
The parts named most often across 203 owner complaints filed with NHTSA for this make, model and year.
1 fire
1 injured
3 crashes · 2 injured
1 fire · 1 injured
2 crashes
1 crash · 1 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
Started with gas smell and I was able to see gas dripping down from fuel pipeline in the rear wheel driver side.
The contact owns a 2011 Chevrolet HHR. The contact stated that while approaching the locked vehicle, the contact noticed that the rear driver's side door had failed to latch securely and was open. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 42,495.
Last week, I noticed fuel leaking out from the bottom of my vehicle on the rear passenger side in my driveway after returning home. I had my vehicle towed into a local shop to get looked at. The shop informed me that my entire fuel line assembly needed to be replaced. They stated that the metal assembly has rusted and corroded over time. At the time of this writing, my vehicle is still in the shop awaiting to get fixed. It is available to be inspected upon request. There are no warning signs on my computer system prior to this. This leaking fuel could have put myself and my family at risk for harm due to the fire risk.
Fuel lines corroded just like millions of other HHR's. Gas is leaking. What does it take to have a recall on this? Does someone really have to be killed?
There is a serious electrical glitch that's in the computer, that causes the car to perform poorly at a slow speed, which cases the steering to become very hard to turn, and maintain lanes while driving. All lights, warnings, and gauges fluctuate back and forth, while the bell inide the car when stared keeps chiming.
Fuel line/gas leaking from faulty tube carrying ignitable flammable fluid...no warning just smell and sighting at stop..went to savoy IL dealer immediately and had replaced @ 1k cost approx. 2+ yrs ago...cel
fuel line leak
Fuel Line is leaking on back left rear. Other models have recall but i have a 2011 with the same exact problem
Fuel line/s started leaking just infront of the left rear wheel about 06/27/2023. Ignition switch started sticking about 06/22/2023.
I left vehicle running on my concrete driveway while I ran in the house to get my father for an errand. When I came outside and went to get into the vehicle I noticed a fire in the front of the rear wheel on the driver's side kind of dripping flames from the vehicle on to the concrete. Luckily I reacted quickly enough to release the parking brake. [Car is a manual transmisson]. The car drifted forward [driveway has small downhill pitch]and I turned the motor off. Then I [luckily] ran over to a hose and brought it to the vehicle to extinguish the fire.
Fuel line is leaking in front of the rear driver's side tire. The lines are heavily corroded. It has not been officially inspected.
The gauge cluster is not working.
Showing 12 of 203 complaints.