Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2015 Chevrolet Silverado 2500, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Chevrolet Silverado 2500 year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA lists 6 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Risk: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.
Campaign 18V578000
Issue: General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Campaign 16V651000
Issue: General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Campaign 17V437000
Issue: General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.
Risk: If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.
Remedy: GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 20760.
Campaign 16V069000
Issue: General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Risk: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
Remedy: Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.
Campaign 21V504000
Issue: General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500 and Chevrolet Silverado 1500 and 2015 GMC Sierra 2500 and 3500, and Chevrolet Silverado 2500 and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator.
Risk: If the end cap separates from the inflator, the compressed gas will escape and the end cap can be propelled into the vehicle, increasing the risk of injury or a crash.
Remedy: GM will notify owners, and dealers will replace the RRAB modules on the left and/or right side, free of charge. Interim owner notification letters were mailed on December 22, 2020. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. Note: GM filed a new recall, number 21V-504 that supersedes this recall. All vehicles previously recalled under 20V-736 will now be repaired under the new recall number 21V-504. GM's numbers for this recall are N202309680, N202309681, and N202309682.
Campaign 20V736000
NHTSA frontal crash test
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2015 Chevrolet Silverado 2500 PU/EC RWD
The parts named most often across 258 owner complaints filed with NHTSA for this make, model and year.
1 crash · 1 fire
1 crash · 5 injured
1 fire
1 injured
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
The contact owns a 2015 Chevrolet Silverado 2500. The contact stated that while inspecting the vehicle, the contact became aware that the front driver’s side wheel stud was fractured and the lug nuts on all four wheels were mismatched. Additionally, the front end wobbled while driving over cracks on the roadway. The vehicle was taken to the dealer, who determined that the front driver’s side wheel stud and lug nuts needed to be replaced and scheduled an upcoming appointment for repair. The failure mileage was approximately 180,000.
LT265/60R20 121S E Yokohama Geolander AT4, manufacturer date of 2924. While driving south on Interstate 95, the driver’s side rear tire sidewall blew out, inside sidewall. The tires have approximately 14000 miles on them. There were no sidewall defects noticed approximately 4000 miles prior during a tire rotation. Nothing was hit in the roadway and proper pressure is maintained in all tires. There was no indication, tpms warning, that the tire was losing pressure prior to the blow out. There does not appear to be any damage to the tread area of the tire. Control of the vehicle was maintained to a stop in the breakdown lane. There were no injuries.
Odometer Fraud. The contact purchased a 2015 Chevrolet Silverado 2500 from an auction. It was later discovered that there was a mileage discrepancy. At the time of the purchase, the vehicle mileage was 73,672. At the time of the vehicle registration, it was discovered that the mileage was 239,567.
What component or system failed or malfunctioned, and is it available for inspection upon request? Truck caught fire in driveway about 5 minutes after parking truck and turning off engine. Truck is still in spot it burned and available for inspection. How was your safety or the safety of others put at risk? If I had been in truck when it caught fire, I could have burned. Has the problem been reproduced or confirmed by a dealer or independent service center? NA Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No
The contact owns a 2015 Chevrolet Silverado 2500. The contact stated that while driving approximately 65 MPH with the rear defroster activated, there was an electrical burning odor inside the cabin of the vehicle before the rear window cracked and then shattered. The cause of the failure was not yet determined. The local dealer and the manufacturer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in the Extended Warranty Coverage related to the failure. The rear window was replaced by the local glass repair shop. The contact stated that the failure reoccurred while driving, and the rear window shattered while a grandson was seated in the rear seat. During the failure, there was no injury sustained. The cause of the failure was not yet determined. The failure mileage was approximately 85,000.
The contact owns a 2015 Chevrolet Silverado 2500. The contact stated that while driving approximately 50 MPH, the vehicle started to vibrate and shudder abnormally. There was no warning illuminated. The contact continued driving at approximately 30 MPH. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact had another 2015 Chevrolet Silverado 2500 in 2025, and the vehicle experienced similar symptoms before the transmission failed. The contact stated that the vehicle was towed to a dealer, who advised that this was a known failure with the 6-speed transmission. The contact was informed by the dealer that the torque converters were too small for the transmission. The manufacturer was not informed of the failure. The failure mileage was approximately 109,000.
My pickup truck has a Duramax diesel engine with a CP4 diesel injection pump. That pump has not failed yet in my truck. However it has been known to fail in numerous other GM vehicles with Duramax engines and when it does fail the engine comes to a complete stop and cannot be restarted. This is a potentially hazardous even fatal situation. Repair if the pump fails is very expensive - $12,000 to $14,000 in some cases. I would like GM to replace the injection pump at my dealership to ensure this known failure does not occur. My pickup truck is otherwise in excellent condition.
IN NOVEMBER AROUND THE 20TH -BATTERY WENT DEAD-CHARGED BATTERY AND TOOK VEHICLE TO BROTHERS AND STARTED TO SHIFT FUNNY-BATTERY WENT DEAD AGAIN-CHARGED AND DROVE HOME -THEN WENT GOT NEW BATTERY -PUT IN AND IT WOULD NOT SHIFT RIGHT SO DROVE IT A LITTLE WHILE TO SEE IF IT WOULD STOP MADE NOISE AND TAKEN TO GARAGE IN SOUTH WAYNE-TOLD US SAID THE TRANSMISSION WAS SHOT-HE HAULED IT TO DUBUQUE IOWA TRANSMISSION SHOP-THEY TOOK IT OUT OF TRUCK AND OVERHAULED IT WITH HEAVY DUTY PARTS-COST OF 6,330.00=MILES AT TIME 51500 BACK MARCH 28 2025-WORKS BEAUTIFUL AS IT SHOULD-SCANED BILL AND ATTACHED-WE NEED REIMBURSEMENT FOR COST.
On 8/25/2025 I purchased a used 2015 Chevy Silverado 2500HD from a auto dealer and they had put new tires on the truck that aren't rated for a 2500 HD, I contacted them and they offered me $400 to replace them with the correct tires that cost me $1319.78 they refuse to help me anymore which is putting my life and others at stake if a tire is to blow out hauling heavy loads that the tires aren't rated for. That 3/4 ton truck is suppose to have tires with a (E) rating, also the TPMS system does't work because all the tires are under inflated for that truck. They have been contacted about this issue; FMVSS No. 120: FMVSS No. 139: FMVSS No. 138 cover this issue! The dealership violated the NHTSA standards and consumer protection laws among other laws.
Steering great box replaced steering still not stable, electrical glitches such as stability trac service message, hill assist, breaking assist messages pop up and then disappear constantly, power steering pump, hydro boost and master cylinder replaced multiple times, no sound emitting for seat belt, door chime , turn signals with no accessory mode power when key is turned. Vehicle has been in and out of shop for repairs and noone can figure out the sound or electrical issues and keep replacing the steering and power steering components. When using driver side window switch all dashboard lights increase in brightness then dim back down
We have been calling and trying to get this recall taken care of. Every time we call they never have the parts and "will let us know". Its getting frustrating getting these notices from different sources and not being able to take care of it. Please help us to het this done by directing us to a repair shop that has the parts available.
TCM stopped working, have been reading how this is a common issue, my truck is currently in the shop and mechanic is having trouble finding a TCM replacement.
Showing 12 of 258 complaints.