Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2003 Dodge Caravan, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Dodge Caravan year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
NHTSA frontal crash test
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2003 Dodge Caravan
NHTSA lists 9 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: EAGLE EYES IS RECALLING 11,534 HEADLAMP ASSEMBLIES, P/NOS. CS090-B001L AND CS090-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE LOWER BEAM PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: EAGLE EYES WILL NOTIFY OWNERS AND OFFER REPLACEMENT HEADLAMPS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2008. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
Campaign 08E048000
Issue: CURT MFG IS RECALLING CERTAIN CLASS 3 RECEIVER HITCHES, P/N 13347, SOLD AS AFTERMARKET EQUIPMENT FOR USE ON 1997-2007 CHRYSLER TOWN AND COUNTRY VANS, 1996-2007 DODGE CARAVANS, AND 1996-2004 PLYMOUTH VOYAGER VANS. WHEN THE HITCH IS LOADED TO THE MAXIMUM RATING, THE HITCH MAY FRACTURE OR BREAK AT THE BEND LOCATION WHERE THE MAIN BODY OF THE HITCH MEETS THE HITCH MUFFLER STRAP.
Risk: IF THE AREA IN QUESTION FRACTURES OR BREAKS, THIS COULD CAUSE AN UNSTABLE DRIVING CONDITION, POSSIBLY RESULTING IN A CRASH.
Remedy: CURT MFG WILL NOTIFY OWNERS OF RECORD AND WILL REPLACE THE HITCH FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CURT MFG AT 1-715-831-8713.
Campaign 10E034000
Issue: MAXZONE IS RECALLING 2,520 HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 3341103L-AS AND 334-1103R-AS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR 2001-2007 DODGE CARAVAN PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: MAXZONE WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON JUNE 16, 2008. OWNERS MAY CONTACT MAXZONE AT THE FOLLOWING LOCATIONS: 1-888-286-1188 (WA, OR, CA, ID, NV, AZ, MT, WY, UT, CO, KS, NM, OK, TX, AR, LA, AK, HI) 1-877-253-8930 (ME, NH, VT, MA, CT, RI, NY, NJ, PA, MD, DE, WV, VA) 1-800-859-4755 (NC, SC, GA, FL, TN, AL, MS) 1-866-783-6858 (ND, SD, NE, MN, IA, MO, WI, IL, MI, IN, OH, KY).
Campaign 08E039000
Issue: CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
Risk: LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
Remedy: AFFINIA (BRAKE PARTS, INC.) WILL REPLACE THE SUBJECT BRAKE HYDRAULIC MASTER CYLINDERS FREE OF CHARGE. THE RECALL BEGAN ON MARCH 20, 2006. OWNERS CAN CONTACT AFFINA GROUP CUSTOMER SERVICE AT 1-800-323-0354.
Campaign 06E022000
Issue: ON CERTAIN MINIVANS, THE POWER LIFTGATE (PLG) LATCH MAY NOT ENGAGE THE STRIKER ALLOWING THE LIFTGATE TO OPEN WHILE DRIVING.
Risk: IN THE EVENT OF A CRASH, AN UNBELTED PASSENGER COULD BE EJECTED FROM THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE POWER LIFTGATE CONTROL MODULE FREE OF CHARGE. THE RECALL BEGAN APRIL 26, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 05V134000
Issue: CERTAIN AFTERMARKET REPLACEMENT FUEL FILTERS, MODELS WIX FILTER PART NUMBERS 33576, 33577, 33734; NAPA FILTER PART NUMBERS 3576, 3577, 3734; AND CARQUEST FILTER PART NUMBERS 86576, 86577, 86734 USED ON 1996-2000 DAIMLERCHRYSLER TOWN & COUNTRY, DODGE CARAVAN, AND PLYMOUTH VOYAGER VEHICLES, CAN CAUSE THE FUEL LINES TO LEAK.
Risk: A POSSIBLE FIRE CAN OCCUR IN THE PRESENCE OF AN IGNITION SOURCE.
Remedy: WIX WILL NOTIFY ITS CUSTOMERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. NOTE: THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER 2003. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WIX AT 704-864-6711.
Campaign 03E053000
Issue: ON CERTAIN MINIVANS EQUIPPED WITH 3.3 OR 3.8L V-6 ENGINE, THE UPPER POWER STEERING COOLER HOSE MAY SPLIT AND CAUSE A FLUID LEAK.
Risk: POWER STEERING FLUID LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN AN UNDER HOOD FIRE.
Remedy: DEALERS WILL REPLACE THE UPPER POWER STEERING COOLER HOSE. THIS RECALL BEGAN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 04V386000
Issue: CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Risk: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000
Issue: AFTERMARKET REPLACEMENT FUEL FILTERS MANUFACTURED BETWEEN SEPTEMBER 17, 2002, AND JANUARY 20, 2003, SOLD UNDER THE BRAND NAMES LISTED ABOVE. THE FILTER MAY EXPERIENCE MALFUNCTION OF THE QUICK CONNECTOR EITHER BLOCKING FUEL FLOW TO THE ENGINE OR CAUSING A FUEL LEAK. THIS DOES NOT INVOLVE ANY PRODUCTS MANUFACTURED BY THE DAIMLERCHRYSLER CORP. NOR ANY DAILMERCHRYSLER DEALERS.
Risk: IF THIS CONDITION OCCURRED WHILE THE VEHICLE IS IN MOTION, THE ENGINE COULD STALL. ALSO, IN THE PRESENCE OF AN IGNITION SOURCE, THE FUEL LEAK COULD RESULT IN A VEHICLE FIRE.
Remedy: AFTERMARKET REPLACEMENT FUEL FILTERS FOR 1995-2000 SHORT WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18232 AND DATE CODE 0237, 0249, OR 0252. REPLACEMENT FUEL FILTERS FOR 1995-2000 LONG WHEELBASE CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 18230 AND DATE CODE 0237, 0249, 0251, OR 0304. REPLACEMENT FUEL FILTERS FOR 2001-2004 CHRYSLER TOWN & COUNTRY, PLYMOUTH VOYAGER AND DODGE CARAVAN MINIVANS PART NO. 28871 AND DATE CODE 0249. THESE PART NUMBERS AND DATE CODES APPEAR ON THE GOLD-TONE FILTER. DISTRIBUTORS AND RETAILERS WILL BE NOTIFIED TO ISOLATE AND RETURN AFFECTED INVENTORY. OWNERS WHO HAVE HAD THE FUEL FILTER SERVICED ON ONE OF THE APPLICABLE VEHICLES AFTER SEPTEMBER 17, 2002 SHOULD RETURN THEIR VEHICLE TO THE SERVICE FACILITY TO BE INSPECTED TO SEE IF THE FUEL FILTER THAT WAS INSTALLED IS ONE THAT IS INVOLVED IN THE RECALL. IF SO, THE OWNERS SHOULD HAVE THE FILTER REPLACED. TO RECEIVE A FULL REFUND PLUS THE COST OF POSTAGE, OWNERS SHOULD CUT THE CONNECTORS FROM THE HOSES, RINSE THE CONNECTORS AND RETURN THEM TOGETHER WITH PROOF OF THE AMOUNT PAID FOR THE REPLACEMENT PART AND LABOR, TO INTERCONTINENTAL AT INTERCONTINENTAL AUTO PARTS, INC., P.O. BOX 861, MAHWAH, NJ 07430, ATTN: FUEL FILTER RECALL. INTERCONTINENTAL WILL MAIL A FULL REFUND TO THE OWNER.
Campaign 03E045000
The parts named most often across 195 owner complaints filed with NHTSA for this make, model and year.
1 crash · 1 fire · 1 death
3 crashes · 1 injured
1 crash · 9 injured
3 fires
1 crash
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
1 complaint-reported fatality on this model.
DRIVING DOWN THE HIGHWAY AT REGULAR SPEED AND ENGINE COMPRESSION SHUT DOWN AND VEHICLE STALLED, AS I BARELY COASTED OFF TO THE SIDE OF THE HIGHWAY, AS THIS SITUATION WAS VERY DANGEROUS..
TL* THE CONTACT OWNS A 2003 DODGE CARAVAN. THE CONTACT STATED WHILE DRIVING AT 25 MPH, THE POWER STEERING STARTED TO FAIL WHICH MADE THE VEHICLE DIFFICULT TO STEER. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED WITH THE UPPER POWER STEERING COOLER HOSE NEEDING TO BE REPLACED. THE CONTACT RELATED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 04V386000 (STEERING) WHICH WAS PREVIOUSLY PERFORMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000.
I WAS DRIVING AND HIT A POT HOLE AND THE REAR AXLE BROKE CAUSE BY CHEAP DESIGN REAR AXLE SUPPORT. AFTER CHECKING OUT YOU TUBE IT IS E COMMON PROBLEM WITH DODGE AND CHRYSLER VANS. IF THIS HAPPENED ON THE HIGHWAY ONE CAN END UP UNDER A 18 WHEELER.
TL* THE CONTACT OWNS A 2003 DODGE CARAVAN. WHILE DRIVING 15 MPH AND ATTEMPTING TO MAKE A RIGHT OR LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. THE VIN WAS NOT AVAILABLE.
AFTER REFUELING ENGINE DIES WHEN PULLING OUT IN TRAFFIC. HAPPENED LAST THREE TIMES AFTER REFUELING.
I HAD ALREADY SENT INFO TO DOL (BELOW) ON 03 CARAVAN I FROM UNLICENSED DEALER MICHAEL RANKIN. PLEASE SEE COMPLAINT FORM INATTACHMENT -IT'S TOO LONG TO ADD. THEY'RE IN PROCESS OF CHARGING MICHAEL RANKIN ON 12 COUNTS FOR DIFFERENT VEHICLES SOLD,AND ASESSING MONETARY FINES. I HAVE DONE TRANSMISSION REPAIRS TO THIS POSTAL FLEET VEHICLE.ACCORDING TO EXPERIENCED MECHANISS AT 32,300 MILES THE TRANSMISSION HAD ALREADY BEEN REBUILT -IMPROPERLY. I'M COMPLAINING BECAUSE I WAS STUCK ON FAST MOVING ARTERIAL WITH LEAKING TRANSMISSION (UNSAFE CONDITION) BECAUSE OF IMPROPER REPAIRS ,AND COULD NOT MOVE THE VEHICLE IN CONJESTED TRAFFIC 1621-72ND ST EAST,TACOMA,WA 98404. VEHICLE WAS STATIONARY AT THAT MOMENT AND AT ANOTHER DIFFERENT TIME WHEN DRIVING.THIS IS THE UNSAFE PART. THE MECHANIC CHARGED ME APPROXIMATELY $1500 AND ALSO TOLD ME IT HAD TRANSMISSION ALREADY REBUILT AND (4) LOOSE BOLTS ON PUMP SEAL, ALSO HAD A "PRE OWNED" USED? WRECKING YARD TORQUE CONVERTER WHICH WAS PAINTED BLACK INDICATING THE REBUILD OCURRED. HE ALSO STATED HOW THE 2 FRONT HALF SHAFTS (AXELS) WERE WORN OUT AND I HAD TO REPLACE THOSE, ABOUT $250. IT HAS BAD POWER STEERING PUMP-AND GROANING NOISES CURRENTLY (UNSAFE CONDITION) JUST LIKE WHEN I GOT IT (32.3K MILES) VEHICLE HAS A BAD AIR CONDITIONER NOT UNSAFE. *I HAVE JPEG PHOTOS AND RECEIPS FOR PARTS,AXELS, TRANSMISSION REPAIR AND FLUID I HAD TO BUY TO KEEP FLUID IN TRANSMISSION. PLEASE SEE ATTACHMENT FOR COMPLAINT SENT TO WASHINGTON DOL , JOSH IS THE CONTACT.
FUEL WIRING HARNESS IS TO CLOSE TO EXHAUST CAUSED MELTING OF WIRES WHILE GOING DOWN THE ROAD. I NOTICED A BURNING SMELL IN THE CABIN OF CARAVAN. IT HAPPENED APPROX. A MILE FROM MY HOUSE AT APPROX 45MPH AND A STRONG ODOR OF GAS WAS NOTICEABLE. THIS IS A SERIOUS ISSUE THAT NEEDS TO BE CORRECTED. VEHICLE BEGAN TO STALL COMING UP DRIVE WAY. WE STILL HAVE THE CARAVAN BUT HAVE PARKED IT. WE BELIEVE WHEN THE MELTING OCCURRED IT CAUSED OTHER POSSIBLE ISSUES AND ARE SCARED TO HAVE IT FIXED, NOT KNOWING WHAT OTHER ISSUES THIS MAY HAVE CAUSED THAT WE WILL NOT KNOW UNTIL WE ARE GOING DOWN THE ROAD, IT'S NOT A RISK I'M WILLING TO TAKE...ESPECIALLY WITH GAS BEING FLAMMABLE AND SHORTENING OF FUEL ELECTRICAL WIRES. THAT'S A FIRE IN THE MAKING, IT'S NOT WORTH RISKING OUR LIVES OR ANYONE ELSE'S ON ROAD. I HAVE SEEN SEVERAL OTHER COMPLAINTS ON REVIEW PAGES AND MECHANICS BLOGS/POSTS. THIS SEEMS TO BE A CONTINUING ISSUE THAT HAS NOT BEEN ADDRESSED. I HAVE SEEN THAT OTHER YEAR MODELS WERE RECALLED DUE TO THE SAME ISSUE BUT NOT THE 2003 DODGE CARAVAN SPORT. CAN YOU PLEASE INVESTIGATE THIS MATTER? IT COULD BE A SIMPLE FIX BY MOVING WIRES AWAY FROM EXHAUST BUT YOU ARE UNAWARE THAT, IT'S A ISSUE, UNTIL IT HAPPENS. BECAUSE IT NOT A VISIBLE HARNESS THAT YOU CAN SEE JUST BY RAISING HOOD.IT'S ONLY WHEN YOU HAVE PROBLEMS THAT YOU REALLY GET TO LOOKING AND THAT'S WHEN YOU SEE IT MELTED AND BURNED WITH STRONG ODOR COMING OUT FROM UNDER HOOD WHEN WE CHECKED IT. ALSO CATALYTIC CONVERTER WAS HOT THIS SHOULD NOT BE A CONSUMER EXPENSE WHEN IT HAPPENS. DUE TO WIRES TO CLOSE TO EXHAUST IT SEEMS TO BE A ISSUE FOR DODGE, SINCE THIS IS DUE TO THEIR FAULT AND NOT THE CONSUMER, DODGE SHOULD BE HELD ACCOUNTABLE FOR COST WHEN FUEL HARNESS WIRES MELTS AND ANY FURTHER DAMAGE CAUSED BY THE WIRES SHORTENING OUT . THIS IS A DANGEROUS/SERIOUS ISSUE THAT I HOPE CAN BE ADDRESSED SOON...BEFORE A LIFE IS LOST.
WAS DRIVING DOWN THE ROAD AIR BAG LIGHT CAME ON TOOK TO MIDDAS HAD INSPECTION $200 LATER LIGHT STILL ON NO ONE KNOWS WHY SCARED IT'S GOING TO BUST WAS ON A STRAIGHT ROAD NO BUMPS
I HAD TIRE SEPERATION ON A FIRESTONE SUPREME SI. I WAS TRAVELING 70 MPH ON THE HIGHWAY. THANKFULLY, NO ONE WAS INJURED AND THERE WAS NO ACCIDENT. THIS IS VERY DANGEROUS AND APPARENTLY HAPPENS QUITE FREQUENTLY. WHY HASN'T THIS ISSUE BEEN RESOLVED?
TL* THE CONTACT OWNS A 2003 DODGE CARAVAN. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE FRONT DRIVER SIDE WINDOW MADE A LOUP POPPING NOISE WHEN IT WAS BEING ROLLED UP. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHERE IT WAS DIAGNOSED THAT THE POWER WINDOW MECHANISM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED LATER AND THE WINDOW DROPPED DOWN INTO THE DOOR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000.
CPSC: I1530226A. 2003 DODGE CARAVAN. CONSUMER STATED THE CAR AIR BAG DEPLOYED AND THE VEHICLE WAS NOT IN MOTION NEITHER DID IT HIT ANYTHING. *LN
WHEN I PUT THE KEY IN THE IGNITION SWITCH SOMETIMES IT WILL NOT TURN ALLOWING ME TO START THE CAR. WHEN I CALLED THE DODGE DEALER THEY SAID THAT THIS IS A COMMON PROBLEM. THEY TOLD ME TO INSERT THE KEY PULL IT TOWARDS ME THEN INSERT A FLAT HEAD SCREW DRIVER IN THE KEY AND TAP 2 TO 3 TIMES THEN TURN THE KEY. I WORKS LIKE THAT EACH TIME BUT THE SYMPTOMS MATCH THOSE DESCRIBED IN TV ADS PROMPTING DANGER OF HAVING THE ENGINE SHUT DOWN WHEN UNSUSPECTING AND CAUSING ACCIDENTS. WHAT CAN BE DONE? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Showing 12 of 195 complaints.