Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2012 Ford Expedition, assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its VIN to decode that exact car, its engine, trim, assembly plant and factory equipment, alongside these records.
Open a VIN recordRecalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ford Expedition year.
No EPA fuel-economy match for this model. Naming may differ, or it predates EPA records.
The parts named most often across 118 owner complaints filed with NHTSA for this make, model and year.
1 crash
Complaints are self-reported and skew toward problems people find alarming, so read this as where to look rather than as a defect rate.
vehicle shifting erratically and shows fuel mileage low and loss of speedometer
vehicle shifting erratically and shows fuel mileage low and loss of speedometer
The contact owns a 2012 Ford Expedition. The contact stated that while his wife was driving 30 MPH, the transmission unexpectedly downshifted, causing the occupants to lunge forward. The tires squealed and the wheels locked up. The vehicle was turned off but failed to restart. No warning light was illuminated. The contact stated the failure was associated with NHTSA Campaign Number: 16V248000 (Power Train). A tow truck company was contacted, and was able to restart the vehicle, but the failure persisted. The local dealer was contacted and confirmed that there was no recall coverage associated with the VIN. The vehicle was not diagnosed or repaired. An attempt was made to contact the manufacturer, but there was no response. The failure mileage was approximately 166,000.
While exiting the freeway at approximately 45 to 50 mph, the transmission downshifted to 1st gear locking up the tires.
The speedometer will quit working and the vehicle will not shift out of 1st gear, if you can work through it it will start throwing error messages such as zero miles to empty, tire moniter system fault, etc. This is a very dangerous situation especially in high traffic areas. There was a customer satisfaction program on it but only up to 150,000 miles. This program should last the life of the vehicle, also, if it was fixed before ownership, why did it go bad again
Over a period of time this problem is occurring more often. The vehicle will downshift into first gear. I pull over check engine light is on. I turn off wait turn back on and no problem for awhile. Within the last month this has occurred many times . Each time the check engine light comes on but also now the advance track light. Each time I have the same codes pulled. Driving on the highway with my daughter at 65mph it downshifted and the back tires locked up . Vehicles had to swerve to miss us. The check engine light was on advance track light same codes pulled. The dealership said it’s not in the recall even though it was built in Jefferson co Kentucky 9/2011. I don’t understand why this vehicle wasn’t recalled . I have to continue to drive it’s my only vehicle. I’m so scared for my life.
The contact owns a 2012 Ford Expedition. The contact stated that the image displayed on the back over prevention screen was either upside down, distorted, static only, or completely black. The failure was intermittent. During the failure, the contact was able to restart the vehicle to fix the image; however, the fix was intermittent. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The contact researched and found information on NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the VIN and model year was not included. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 78,000.
I was driving my 2012 expedition and suddenly the vehicle went from doing 60 to 40 immediately the tires squealed and threw me into the right lane . This vehicle transmission has a recall for down shifting and power train issues. My vin number does not fit the Recall but my vehicle has all the symptoms of multiple recalls and is not safe to drive . Had i not known how to drive i and my daughter would be in the hospital due to the faulty transmission lead frame and power train . I contacted Ford head quarters they were no help even though there is clearly a recall . I also took the truck to ford of valparaiso and had to pay the 1,000 dollars for the lead frame to be replaced which was in the recall and I shouldn't have had to pay anything .. them replacing the lead frame did nothing the car is still not drive able and is extremely unsafe its my only vehicle and I am a single mother of 2 kids .
ABS CPU control system. Error Code B1342-EC. Antilock braking system electronic control unit defect.
JULY 2025 MY 2012 FORD EXPEDITION THREW A P0742 CODE FOR A STUCK TORQUE CONVERTER CLUTCH. THE VEHICLE HAD JUST UNDER 150K MILES AND STARTED TO JERK IN AND OUT OF GEAR AND THE WRENCH LIGHT ILLUMINATED SO I, THANKFULLY WAS GOING APPROXIMATELY 45 MPH WHEN IT HAPPENED AND WAS ABLE TO PULL THE VEHICLE OVER AS IT WAS IN LIMP MODE. WHEN I CLEARED THE DTC CODE THE PROBLEM WENT AWAY TEMPORARILY BUT EVENTUALLY LOCKED BACK UP AGAIN WITHIN A MILE FROM MY HOME. UNFORTUNATELY, FORD DEALERSHIPS WILL NOT STAND BEHIND THE CUSTOMER SERVICE NUMBER THAT THEY HAVE LISTED FOR A REPLACEMENT OF THE TRANSMISSION LEAD FRAME. I PROVIDED THE LOCAL DEALERSHIP WITH ALL OF THE NECESSARY INFORMATION AS WELL AS AN INDEPENDENT DIAGNOSIS BY A TRANSMISSION SPECIALIST. LOOKS LIKE I'LL JUST HAVE TO WAIT FOR THE DAY THAT IT CAUSES A MASSIVE ACCIDENT BY DOWNSHIFTING INTO 1ST GEAR AT 65MPH. TERRIBLE CUSTOMER SERVICE AND I CAN ONLY HOPE THIS DOESN'T COST SOMEONE THEIR LIFE.
I just purchased (2 months ago) a 2012 Ford Expedition EL 5.4l v8 from a private party. I wish I would have done more research as I am ALREADY EXPERIENCING TRANSMISSION ISSUES THAT I BELIEVE ARE DIRECTLY RELATED TO THE VEHICLES LEAD FRAME RECALL. IT THREW A P0742 CODE ON ME Torque Converter Clutch Circuit stuck on and decided that it would only drive in limp mode unless I cleared the code, pulled over, cycles the key, and restarted the vehicle. Even as dangerous as this UNEXPECTED SHIFTING INTO 1ST GEAR AT HIGHWAY SPEEDS IS, IT IS EQUALLY AS DANGEROUS TO BE GETTING OUT OF YOUR VEHICLE IN MOVING TRAFFIC DUE TO FORD'S TERRIBLE DESIGN ON THIS VEHICLES POWER TRAIN/TRANSMISSION SYSTEM. I HAVE SCHEDULED AN APPOINTMENT WITH THE LOCAL Ford DEALER AND AL CERTAIN I'LL GET THE RUNAROUND/BLAME GAME FOR THIS ONE. 150K MILES AND AS I said, I HAVE OWNED IT FOR 2 MONTHS AND HAVE ALREADY HAD TRANSMISSION ISSUES, BRAKE ISSUES, BELT TENSIONER PULLEY LITERALLY FELL OFF.. AND FROM WHAT I READ, WHAT'S NEXT??? THE CAM PHASERS?? THAT'S IF THE TRANSMISSION ISSUE IS EVEN FIXED AND IT BECOMES SAFELY DRIVE ABLE AGAIN. COME ON FORD, GET YOUR ACT TOGETHER, YOU'RE BETTER THAN THIS!
Campaign 19N01 Description Transmission molded leadframe extended coverage Next Steps Contact your dealer for next steps. Did this and was told that the vehicle was not covered due to it being after 10 years and barely over 150,000 miles. I am experiencing transmission issues where the torque converter clutch is now stuck on and the lead frame is more than likely the cause. Thanks FORD, NEVER AGAIN.
Showing 12 of 118 complaints.
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2012 Ford Expedition EXTENDED SUV 4x4
NHTSA lists 3 recalls for this make, model and year. Recalls apply to the model, so some may already be fixed on this specific car. A dealer can confirm from the VIN.
Issue: Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford F-150 trucks, 2012 Ford Expedition, Lincoln Navigator, and Ford Mustang vehicles. The affected vehicles are equipped with an automatic transmission that may unexpectedly downshift to first gear, regardless of vehicle speed.
Risk: An unexpected downshift into first gear can cause the vehicle to slow down suddenly without warning and the rear tires may slide or lock, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the powertrain control module with updated software, free of charge. The recall began on September 19, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S19.
Campaign 16V248000
Issue: FORD IS RECALLING CERTAIN MODEL YEAR 2011-2012 FORD F-150, 2012 EXPEDITION AND LINCOLN NAVIGATOR, AND 2012-2013 MUSTANG VEHICLES, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NOS. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT" AND 108 LAMPS, REFLECTIVE DEVICES AND ASSOCIATED EQUIPMENT. THESE VEHICLES MAY HAVE A TRANSMISSION RANGE SENSOR (TRS) THAT WAS CALIBRATED OUT OF SPECIFICATION FOR REVERSE GEAR.
Risk: IF THIS CONDITION EXISTS, THE TRANSMISSION MAY NOT GO INTO REVERSE OR WHEN THE DRIVER PUSHES THE SHIFT LEVER IN THE REVERSE R POSITION AND THE VEHICLES TRANSMISSION DOES GO IN REVERSE, THE R MAY NOT ILLUMINATE ON THE DASHBOARD OF THE F-150, EXPEDITION, OR NAVIGATOR MODELS AND/OR THE BACKUP LAMP ON THE REAR OF THE F-150, EXPEDITION, NAVIGATOR, OR MUSTANG VEHICLES MAY NOT ILLUMINATE. THESE CONDITIONS INCREASE THE RISK OF A CRASH OR A PEDESTRIAN BEING STRUCK DUE TO THE VEHICLES NOT SIGNALING IT IS IN REVERSE.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND REPLACE THE TRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 12V190000
Issue: FORD IS RECALLING CERTAIN MODEL YEAR 2012 EXPEDITION AND LINCOLN NAVIGATOR VEHICLES, MANUFACTURED FROM NOVEMBER 19, 2011, THROUGH DECEMBER 2, 2011, FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINTS." THESE VEHICLES MAY HAVE INADEQUATE WELDS ON THE HEAD RESTRAINT SUPPORT BRACKETS FOR THE SECOND ROW, RIGHT-HAND SEAT.
Risk: IN THE EVENT OF A CRASH, THE SEAT HEAD RESTRAINT MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.
Remedy: FORD WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE HEAD RESTRAINTS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 21, 2012. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 12V034000