Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2012 Ram 2500 — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Ram 2500 year.
No EPA fuel-economy match for this model (naming may differ or it predates EPA records).
NHTSA lists 5 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: Chrysler (FCA US LLC) is recalling certain model year 2012-2014 Ram 1500, 2500, 3500, 4500, and 5500 trucks manufactured January 18, 2011, to October 7, 2014, and equipped with the Electronic Vehicle Information Center option. The affected vehicles have a steering wheel wiring harness that may rub against the driver air bag module retainer spring.
Risk: This abrasion may result in an electrical short that could cause driver's frontal air bag to unexpectedly deploy. Inadvertent deployment of the air bag may increase the risk of injury and the possibility of a vehicle crash.
Remedy: Chrysler will notify owners, and dealers will inspect, repair as necessary, and secure the steering wheel wiring harness. Additionally, protective caps will be added to the air bag retainer spring ends. These repairs will be done free of charge. The recall began on September 18, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R36.
Campaign 15V459000
Issue: Chrysler (FCA US LLC) is recalling certain 2016-2017 Ram 3500 Cab Chassis with a Gross Vehicle Weight Rating (GVWR) of less than 10,000 lbs, 2011-2017 Ram 3500, 4500 and 5500 Cab Chassis vehicles, 2009-2017 Ram 1500 and 2010-2017 Ram 2500 and 3500 pickup trucks, all equipped with a column shifter. Pushing the brake pedal for prolonged periods when the vehicle is running and in PARK may cause the Brake Transmission Shift Interlock (BTSI) pin to stick in the open position. With the pin in the open position, the transmission can be shifted out of PARK into any gear without pushing the brake pedal or having the key in the ignition.
Risk: Being able to shift the transmission without pushing the brake pedal and/or without a key in the ignition can increase the risk of an unintended vehicle rollaway that may result in personal injury or a crash.
Remedy: Chrysler will notify owners, and dealers will update the vehicle software, inspect the BTSI, and, as necessary, replace it, free of charge. The recall began February 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is T79.
Campaign 17V821000
Issue: Chrysler (FCA US LLC) is recalling aftermarket Mopar Canvas Seat Covers for certain 2012-2016 RAM 1500, 2500, and 3500 trucks. These Mopar canvas seat covers were sold through Chrysler dealerships beginning October 15, 2015. The seat covers can impede the deployment of the seat thorax airbags.
Risk: If the seat cover impedes the air bag deployment, the seat thorax air bags may not provide adequate protection in the event of a crash, increasing the risk of a injury.
Remedy: Chrysler will notify owners to remove the front seat covers and return them for a full refund. The recall began on July 1, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S30.
Campaign 16E041000
Issue: Chrysler Group LLC (Chrysler) is recalling certain model year 2008-2012 RAM 2500 4X4 and 3500 4X4 trucks, 2008-2012 Dodge RAM 3500 4x2 Cab Chassis, and model year 2008 Dodge RAM 1500 Mega Cab 4x4. The left tie rod assembly may break.
Risk: A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.
Remedy: Chrysler notified owners on January 16, 2014 that dealers would inspect vehicles and replace the steering linkage assembly, if necessary. On or about February 27, 2014, Chrysler ceased its recall remedy program due to parts quality concerns, and then re-initiated it on or about April 14, 2014. In July 2015, and under a consent order with NHTSA, the company agreed to offer owners three options for remedying their vehicles: perform the original remedy, offer to repurchase the vehicle at the fair market value plus 10%, or offer an additional incentive offer towards the purchase of a new Dodge, Jeep, Chrysler, or Fiat vehicle. Chrysler will notify owners of the new recall options in a letter expected to be mailed on August 31, 2015. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N49.
Campaign 13V529000
Issue: Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2014 Ram 2500, 3500, 4500, and 5500 trucks manufactured March 27, 2009, to September 5, 2013. In the affected vehicles, the electrical connectors of the diesel fuel heater may overheat.
Risk: If the connectors overheat, the fuel heater may leak fuel, increasing the risk of a fire.
Remedy: Chrysler will notify owners, and dealers will replace the harness side connector with a silver plated beryllium copper terminal service kit, and inspect the fuel heater for leaks, replacing it as necessary, free of charge. Chrysler issued interim notification to owners on December 8, 2014. The recall began on April 27, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is P65.
Campaign 14V635000
3 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2012 Ram 2500 Mega PU/EC 4WD
The parts named most often across 282 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
3 fires
1 crash
1 fire
1 fire
1 crash
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
We purchased our 2012 Dodge Ram heavy duty with tow package new. At just over 152000 miles, the engine started knocking while on vacation. We were not towing at the time. We put in injector cleaner to try and help the knocking. During our vacation, we were on the freeway when we suddenly lost power, the service engine light popped on, and the engine died. We were literally driving one minute and the next were trying to get out of the traffic lane with no control. We restarted the engine, the knocking had stopped and power was restored. Two days later, another episode of power decrease but with no engine service light. We used premium gas, injector cleaner and listened for the knocking that came and went, to drive home. We were told by our local dealership it is a lifter failure and the truck needs a replacement engine.
My passenger headlights keeps going in and out. The wiring harness has been replaced twice and it still does it. My check engine light keeps coming on for the evap system even though its been replaced.
Our 2012 RAM 2500 truck with 135k miles, had it's fuel tank fail. The dealership in Oak Ridge, TN tested the vehicle and found that the gas tank tubes were broken causing us to not be able to fill the tank. The dealership recommended "NEED TO REPLACE GAS TANK". Mopar aka Stellantis does not make the fuel tank anymore, the "replacement" fuel tank does not work (completely wrong configuration), there is not an aftermarket tank. We have a Million Mile bumper to bumper warranty with MOPAR. "Customer Care" does not care.
Recall T79 or 17V-821 or break transmission shift pin stuck in open position. This is the 2nd time this has happened and serious damage has occurred to the vehicle. Dodge won't do anything about it. Vehicle was parked, turned off, no key. I came out of building and it shifted into gear on its own and rolled backwards into a pole.
The contact owns a 2012 Ram 2500. The contact stated while driving at an undisclosed speed, the vehicle drove over a bump in the roadway and started to shake violently. The vehicle was taken to an independent mechanic where it was determined that the reinforcement bracket over the front track bar bracket had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. Neither the dealer nor the manufacturer were notified of the failure. The failure mileage was approximately 205,000.
The contact owns a 2012 Ram 2500. The contact stated while the vehicle was parked, the vehicle rolled away. The contact was standing near the vehicle with the key fob. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 17V821000 (Power Train). The manufacturer was not contacted. The failure mileage was approximately 220,000.
The contact owns a 2012 Ram 2500. The contact stated the vehicle failed to start intermittently. The contact also stated that the air bag warning light was illuminated. The vehicle was taken to the local dealer and the dealer was made aware of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 168,000.
I purchased a pair of Treadwright warden tires for the rear of my wife’s truck. In less than 100 miles the tread separated from the casing on one of the tires. I caught it before it completely blew out and have pictures. The replacement they sent has a blown sidewall. I mounted it and a bubble started to form that was 1/2” high and 3” around with just 20psi, operating PSI for the tire is 80PSI. I immediately stopped inflation and contacted Treadwright. They tried to convince me that it was “overlap” and safe to use. I told them it is not over lap and showed them multiple pictures of the tire from different angles to prove it has a blown belt. They still insisted it was a serviceable tire. It’s not and I have pictures. I’ve used Treadwright tires for the last 5 or so years. Over the last year and a half to 2 years I’ve received 6 defective tires. All defects were fatal defects, all being broken belts. That’s 1 out of every 4.5 tires purchased. If I’ve received that many fault tires I can be the only one. On top of that the insistence of Treadwright trying to convince people to use fatally defective tires is negligent, reckless and dangerous.
While driving, my dodge shut off and it was hard to control my vehicle and come to a safe stop, out of the way of other motorists. Lost all power, as if I turned the key off while driving. Turns out that there is a weak/loss of connection in the WIN module. while the vehicle is running at idle, the truck will shut off as if I turned the key to the off position. This is dangerous and scary. There was no warning or heads up or any issues prior to this incident.
Tie rod end sheared/broke causing the vehicle to be un-stearable. Fortunately, it happened as I was backing out of my driveway.
Exhaust Manifold on passenger side is leaking. It has a broken bolt due to manifold warping. This is causing exhaust to leak into the cab.
The contact owns a 2012 RAM 2500 equipped with Kenda Tires, Tire Line: Klever, Tire Size: LT275/70/R18, DOT Number: 02T6NAANL12228260. The contact stated while driving 60 MPH, the vehicle started bouncing. The contact stated no warning light was illuminated. The contact continued to drive back to the tire shop and was informed that the front passenger’s side tire was showing tread separation. The tire shop replaced the front passenger’s side tire. The contact stated that approximately two weeks later, he experienced the same failure with the front driver’s side tire. The contact took the vehicle back to the tire shop and had the front driver’s side tire replaced with the spear tire. The vehicle was not diagnosed or repaired. A dealer was not contacted. The contact stated that he had left a voicemail with the manufacturer but had not yet received a callback. The failure mileage was approximately 151,000.
Showing 12 of 282 complaints.