2016 Volkswagen Golf GTI

While driving my 2016 Volkswagen GTI MK7 Autobahn Edition with approximately 37,000 miles, the power steering suddenly and without warning failed completely. The steering wheel became extremely difficult to turn, requiring significant physical force to operate. Simultaneously, both the TPMS (Tire Pressure Monitoring System) warning light and the ESC (Electronic Stability Control) warning light illuminated on the dashboard. I brought the vehicle to an authorized Volkswagen dealership, Deel Volkswagen in Miami, Florida. The dealership diagnosed the issue as a complete failure of the steering rack and pinion assembly and quoted approximately $6,000 for replacement. This failure occurred at only 37,000 miles — far below any reasonable expectation of component life for a steering rack, which should last well over 100,000 miles under normal use. The failure was sudden, with no prior warning signs or gradual degradation. A sudden and total loss of power steering assist while driving at any speed constitutes a serious and unreasonable safety risk, as it dramatically increases the force required to steer and can cause loss of vehicle control. A review of MK7 GTI owner forums and communities reveals this is a recurring and documented issue among this vehicle population, suggesting a systemic defect in the steering rack assembly used in this model. I am requesting that NHTSA investigate whether a safety defect exists in the 2016 Volkswagen GTI steering system that warrants a recall and manufacturer-funded remedy.

NHTSA Recall 24V-110 (VW 20UF). The vehicle is in Limp Mode and experiencing low oil pressure symptoms. It is also subject to Recall 24V-110, which identifies a fire risk due to fuel leakage. Despite the safety hazard, the local Volkswagen dealership has refused to perform the recall repair or diagnose the vehicle, stating it is at their 'discretion.' I am reporting a failure by the manufacturer and the dealer to remedy an active safety defect, leaving me with an unsafe, undriveable vehicle."

I am reporting a safety concern related to Safety Recall 20UF on my 2016 Volkswagen Golf GTI SE and the handling of this recall by an authorized Volkswagen dealership (Pohanka Volkswagen, Capitol Heights, MD). Prior to the recall service, the vehicle exhibited loss of power, intermittent shuddering, and severe difficulty refueling (fuel pump nozzle repeatedly shut off even with a low fuel level). These symptoms were similar to prior EVAP system failures that required replacement of the charcoal canister and EVAP purge (N80) valve earlier in 2025. I brought the vehicle to the dealership on December 29, 2025, specifically requesting completion of Recall 20UF and inspection/replacement of EVAP components if necessary. The dealership initially refused to perform the recall unless I returned the vehicle with less than one-quarter tank of fuel, despite the recall documentation specifying that fuel extraction equipment (VAS5190A or equivalent) is required for this repair. A diagnostic report generated by the dealership listed a “Fuel Pump (in tank)” replacement as a customer-pay repair before later removing it once it was identified as recall-related. After significant delays, the dealership stated the recall had been completed and declined to replace any EVAP components. Since the recall service, the vehicle continues to experience intermittent shuddering and difficulty accelerating. While refueling has temporarily improved, drivability concerns persist, raising questions about whether the recall repair was properly performed and whether the vehicle remains safe to operate. I am concerned about inconsistent handling of a safety recall, improper diagnostic practices, and continued fuel-system-related drivability issues that may pose a safety risk.

Fuel is leaking from near the gas tank when the car is running and creates a puddle- I took my car to the local VW dealership in February to get the Suction Jet Pump Recall completed.

I was driving on the highway, and heard a quiet sound like someone sprinkling sand on my windshield for about 10 seconds. All of a sudden, the sun roof burst and shattered with a loud pop. Luckily the internal slide-able screen webbing kept the glass from entering the compartment (except a bit of glass dust and small shards). I never heard a rock hit, or any other cause. I believe the ‘sand sprinkling’ sound was the ‘spider web’ cracks spreading prior to the burst. Obviously that is extremely dangerous while driving on the highway. If it wasn’t for the internal screen keeping the glass off me, it could have been much worse. I was able to pull off the highway and temporarily secure the glass with some cardboard and packing tape.

I was driving my vehicle on the highway when a driver stopped me and warned me that my vehicle was leaking a huge amount of gasoline. I had a technician inspect the car to see if it might be a fuel line, the technician told me the fuel.lines were good and there were no signs of the gas coming from the lines and no cracks on the tank either. I received a letter from Volkswagen about the recall and I researched it and it says that if that is the problem the car would be leaking gas and it was dangerous as an ignition might cause a fire. I towed my vehicle to the Volkswagen here in Laredo after calling and speaking to someone from service and told yes I could bring it in and the recall part would be replaced free but I would have to leave the vehicle there. When I arrived they told me I would have to pay a diagnostic of 185 dlls and the repair. Which was not what I was told when I called earlier. So I had to pay again to have the vehicle removed from the premises without having the recall part changed.

Repeated issues with leaking water pump and broken seals under the intake manifold causing vehicle to be underivable.

Car began spraying fuel upon turning the key in the ignition. Recall work pertaining to the suction jet pump was recently performed and is the only likely cause of this issue. Car did not leak when fuel pump was disengaged. Very lucky that issue occurred in a parking lot while not moving and did not lead to a fire or crash.

My EPC light began to appear randomly in early 2024. I received a recall notice on the gear shift trim around the same time, so called Jack Ingram VW in Montgomery to schedule a time for them to fix it (and also ensure they had the part). I asked them to also check on why the EPC light was coming on. Brought in my car on 2/28/24. Service Dept then tells me they weren't sure what was causing the EPC light to come on, and they didn't have the gear shift trim part. They quoted me a lot of work to do, which I wasn't prepared financially to have completed. EPC light continued to appear at random. Each time it did, my car would shake and it would feel like I was losing control of the vehicle. I received another recall notice for the suction jet pump inside the fuel tank. When I called Jack Ingram VW to schedule this work, I asked if this had anything to do with my EPC light coming on. They weren't sure. The recall work for both the suction jet pump inside the fuel tank and the gear shift trim were completed on 8/28/24. Car worked fine until about a month later and the EPC light came on again. Called another VW mechanic in Montgomery (Powell's Automotive) to see if they can fix it. On 9/20/24 they replaced battery, spark plugs, ignition coil, and did an oil change. Worked great until [XXX] when my engine failed and left me stranded in the road. There were no warning lights prior to the engine failing. Could not restart car. Had it towed to Powell's who could not fix it, then to Jack Ingram VW. I asked them if this had anything to do with the recall work that was done. They said this would be the first if it was. They told me the in tank fuel pump needed replacing. Work completed 10/25/24. How can they work on the suction jet pump inside the fuel tank and not get a diagnostic that the in tank fuel pump was failing? I've already paid a lot of money to try to resolve the issue, and my EPC light is still coming on. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Volkswagen GTI. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The contact stated while the vehicle was parked, the contact became aware of fuel leaking from the rear of the vehicle. The vehicle was towed to the dealer where the vehicle was diagnosed with a fuel leak coming from the fuel tank suction pump. The contact was informed that the fuel tank suction pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000. VIN tool confirms part not available.

The contact owns a 2016 Volkswagen Golf. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated while starting the vehicle, there was an abnormally strong fuel odor inside the vehicle. The vehicle was taken to the dealer, where it was diagnosed that the fuel tank suction jet pump had failed, causing damage to the fuel tank. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 36,018. VIN tool confirms parts not available.

The contact owns a 2016 Volkswagen Golf. The contact stated there was fuel leaking from the charcoal canister. The contact received notification of NHTSA Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 41,000.