Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2012 Volkswagen Touareg — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every Volkswagen Touareg year.
27.5 mpg average · 25–28 range · EPA says 22
Over 5 years this costs $6,750 more in fuel than an average new vehicle.
NHTSA lists 2 recalls for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2016 Eos, 2012 Passat, 2012-2016 CC, 2015-2016 e-Golf, 2011-2015 Touareg, 2012-2015 and 2017 Tiguan, and 2011-2016 Golf and 2011-2013 GTI vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Risk: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or Volkswagen will repurchase them if necessary, free of charge. The recall began November 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298.
Campaign 18V329000
Issue: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2011-2016 Touareg vehicles. The brake pedal pivot pin may be missing a securing clip, allowing the pivot pin to move and the brake pedal to dislodge.
Risk: If the brake pedal dislodges, the driver may not be able to apply the brakes, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect the brake pedal assembly to verify the presence of the securing clip and install any missing securing clips, free of charge. The recall began on April 27, 2016. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 46G4.
Campaign 16V170000
1 open NHTSA investigation into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2012 Volkswagen Touareg SUV AWD
The parts named most often across 28 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
1 crash · 1 injured
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
After driving the car for approximately 30 minutes without any problems and turning it off, it would not turn the ignition back on, release the parking brake or shift out of „P“. Several towing companies were unable to tow the vehicle due to the manufacturer’s failure to provide instructions on how to release the shifter in case of a problem. Other vehicles have a release button somewhere, the 2012 VW Touareg doesn’t. On page 481 of the owners manual VW advises the owner that if „you want to have the vehicle towed, the gear shift selection lever must first be released with the emergency procedure. Get professional assistance.“ The manual doesn’t explain what this emergency procedure would be. We had to call 3 different towing companies with professionals who didn’t have any clue in regards to the question how to release the shifter. The fourth company came with special equipment which allowed to tow the vehicle with the shifter in „P“ The dealership found that the ESL module (electronic steering lock) was faulty, which could be a safety issue, especially if it actuates while driving the vehicle.
I was driving to church on the morning of 2/16/25 when I heard a very loud “Boom.” I thought something had hit the car. It sounded like a gun going off. When I pulled over to see what had happened I realized the right side mirror had exploded. The glass was completely gone with only the glue left on the back plate housing. Both mirrors were in the “off” position. Nothing hit the outside housing. The right side mirror simply exploded. Thank God the window was not down with a passenger in the right front seat. In cool weather I often drive with the window down. Someone could have been hurt. I have owned many cars but NEVER one with a side mirror that exploded. This design is DANGEROUS.
While driving my family around, the car lost engine power and came to a stop on a busy roadway leaving us stranded until a tow truck could arrive. There were no warnings or indications that anything was wrong. One minute, it was driving fine and out of nowhere, the engine shut off in the middle of the road leaving us blocking a lane and creating a dangerous situation. The dealership is claiming that the high pressure fuel pump suffered a catastrophic failure and that the entire fuel system needs to be replaced, which is going to cost more than $13,000.
The contact owns a 2012 Volkswagen Touareg. The contact stated while driving at an undisclosed speed, he smelled an oil odor and smoke odor in the interior of the vehicle. After a visual inspection, the contact observed oil leaking from underneath the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who determined the diesel particulate filter needed to be replaced but was unable to locate the part. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 124,000.
The contact owns a 2012 Volkswagen Touareg. The contact stated that the driver’s side seat belt unintendedly unlatched while driving at various speeds. Additionally, the contact stated that the clockspring was defective, causing several failures with the vehicle. The contact stated while tilting the steering wheel, the vehicle drifted away from the intended direction and the windshield wipers would activate to the fastest speed with windshield washer fluid spraying onto the windshield and the horn was blaring uncontrollably. The vehicle was taken to a dealer and the contact was provided an estimate for a diagnostic test. The manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was approximately 178,000.
The contact owns a 2012 Volkswagen Touareg. The contact stated that there was an abnormal gasoline odor on the driver’s side of the vehicle. There were no warning lights illuminated. The contact looked underneath the vehicle at the gas tank and noticed that gasoline was leaking from the fuel tank onto the exhaust pipe. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact related the failure to NHTSA Campaign Number 17V151000 (Fuel System, Gasoline). The VIN was not included. The approximate failure mileage was 119,000.
THE DRIVER SEAT BELT DOES NOT LATCH PROPERLY AND COMES OFF WHILE DRIVING. MULTIPLE ATTEMPTS ARE REQUIRED FOR THE SEAT BELT TO LATCH AND BE SECURE. THIS PROBLEM STARTED AROUND JULY 2020.
THE CATALYTIC CONVERTER COMPLETELY SEPARATED FROM ITS OWN FLANGE WHERE IT CONNECTS TO THE EXHAUST HEADER. ULTIMATELY CAUSING AN EXHAUST LEAK AND A CHECK ENGINE LIGHT. THIS OCCURRED WHILE DRIVING AND UNDER NORMAL OPERATING CONDITIONS. DRIVING ON A LOCAL HIGHWAY WITH A SPEED LIMIT OF 55 MPH, WHICH DOES NOT HAVE EXCESSIVE AMOUNT OF POT HOLES) .
THERE HAS BEEN A SUBSTANTIAL CHANGE/DECREASE IN THE PERFORMANCE OF MY 2012 TOUAREG TDI RESULTING IN SIGNIFICANTLY REDUCED FUEL ECONOMY: PREVIOUS AVG FUEL ECONOMY WAS APPROX 27MPG AND IS NOW BARELY AVERAGING 16 MPG. NOTICED CONTINUAL DECREASE IN CAR PERFORMANCE AFTER TAKING MY CAR IN FOR GENERAL MAINTENANCE TO GARCIA VW DEALERSHIP IN SANTA FE, NM ON THE FOLLOWING DATES: 3/6/18: GENERAL MAINTENANCE (AIR/CABIN/FUEL/ADBLUE MAINTENANCE/ AND TIRE CHANGE) 4/17/18: REPLACE A FAULTY RADIO WHICH SUDDENLY FAILED (DEALERSHIP HAD CAR FOR 8 DAYS) 6/7/18: CLEAN UP AD BLUE FUEL SPILL IN THE REAR SPARE TIRE COMPARTMENT THE ENGINE NOW RUNS SIGNIFICANTLY LOUDER AND IS REVVING UP AND SURGING AT INTERVALS. IN ADDITION TO THE SUBSTANTIAL DROP IN FUEL ECONOMY, THE AVERAGE SPEED/MPH HAS BEEN LOCKED AT 13MPH AND DROPPED TO 12MPH ON JUNE 1, 2018. CHANGE IN ENGINE BEHAVIOUR: -ENGINE RUNS LOUDER AND IS REVVING UP WHEN IDLING,ACCELERATING, BREAKING,DOWNSHIFTING -SOUNDS LIKE THE FUEL INJECTION IS SLUGGISH WHEN ACCELERATING -STEERING WHEEL FEELS SLUGGISH WHEN TURNING RIGHT AND ACCELERATING THROUGH TURNS. VIBRATING SOUND WHEN TURNING. -STARTING IGNITION: LONGER PAUSE FOR IGNITION TO START AFTER TURNING THE KEY AND FOOT IS ON BRAKE. -SUSPENSION: SUSPENSION OF THE CAR ROCKS BACK AND FORTH WHEN BRAKING AND SOUNDS LIKE THERE'S A TANK SLIDING/ SHIFTING IN THE REAR WHEN COMING TO A STOP. WHEN I INITIALLY HEARD THIS SOUND I OPENED THE TRUNK/CARGO AREA FOR THE SPARE TIRE AND FOUND DRIED AD BLUE SPILLED ALL OVER THE CARGO AREA INCLUDING DIRTY RAGS WHICH HAD BEEN USED TO WIPE UP ADBLUE AND STUFFED IN THE BOTTOM OF THE TRUNK. -AIR CONDITIONER IS EMITTING A VERY STRONG NAUSEATING YEAST ODOR THAT WILL NOT GO AWAY AND ISN'T COOLING EFFICIENTLY. I HAVENT AUTHORIZED OR APPROVED ANY UPDATES MODIFICATIONS TO THE VEHICLE RE: THE 3.0 LITER GEN EPA/CARB MODIFICATIONS: I SUSPECT VEHICLE TAMPERING.
THIS HAPPENED TO THIS MY 2012 TOUAREG. THE ENGINE RANDOMLY DIED, EVEN ON FREEWAY, WHICH IS TOO DANGEROUS. THE PREVIOUS TIME IN IN JAN,2018 AND THIS TIME WAS ON FEB, 5TH, 2018. I WENT TO VW DEALERSHIP, THEY COULDN'T FIND OUT ANYTHING. SAYING EVERYTHING IS NORMAL AND THEY COULDN'T SUGGEST ANYTHING. BUT IT IS EXTREME UNSAFE FOR ME TO DRIVE THIS CAR. THE ISSUE RANDOMLY HAPPENS. PER HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4965979-CAR-RANDOMLY-DIES-WHILE-DRIVING-ON-FREEWAY, SEEMS THIS IS A COMMON ISSUE AMONG VW VEHICLES, AND PEOPLE THOUGHT IT IS HIGH PRESSURE FUEL PUMP PROBLEM OR OTHER RELEVANT PARTS. VW SHOULD TAKE IT SERIOUSLY AND FIND OUT THE ROOT CAUSE AND FIX IT. THANKS, LIANG
TPMS LIGHT INTERMITTENTLY STARTED BLINKING. I TOOK IT TO THE DEALER AND THEY "DIAGNOSED" IT AS THE BACK LEFT SENSOR. I WAS INITIALLY TOLD THAT THE RECOMMENDATION WAS TO NOT CHANGE IT UNTIL I REPLACED TIRES AND THEN I WAS TOLD IT WAS NOT COVERED UNDER MY WARRANTY. I CALLED THE WARRANTY COMPANY AND THEY SAID THAT IT WAS 100% COVERED.
CHECK ENGINE LIGHT CAME ON AT 70,000 MILES AND WAS DUE TO THE AD BLUE TANK HEATER.
Showing 12 of 28 complaints.