Open safety recalls, the components owners report failing most often, crash-test results and running costs for the 2004 BMW X3 — assembled from NHTSA and EPA records.
Everything on this page applies to the model as a whole. Run its 17-character VIN to decode that exact car — its engine, trim, assembly plant and factory equipment — alongside these records. Free, no account.
Run a VIN →Recalls and complaints are filed against a specific model year, so figures differ from one year to the next even within a single generation. See every BMW X3 year.
Over 5 years this costs $11,250 more in fuel than an average new vehicle.
NHTSA lists 1 recall for this make/model/year. Recalls apply to the model, so some may already be fixed on this specific car — check with a dealer using the VIN.
Issue: BMW IS RECALLING 200,000 MY 2006 3 SERIES SPORT SEAT, MY 2004-2006 5 SERIES STANDARD AND SPORT SEAT, AND MY 2004-2006 X3 PASSENGER VEHICLES. DEPENDING ON THE MANNER AND FREQUENCY OF THE FRONT PASSENGER'S ENTRY AND EXIT, SMALL CRACKS HAVE DEVELOPED IN THE MAT. IF THIS OCCURS, THE FRONT PASSENGER AIR BAGS, WITH THE EXCEPTION OF THE HEAD PROTECTION SYSTEM, WILL BE DEACTIVATED AND THE AIR BAG WARNING LAMP AS WELL AS THE PASSENGER AIR BAG "ON-OFF" LAMP WILL BE ILLUMINATED.
Risk: IN THIS SITUATION THE FRONT PASSENGER AIR BAGS WILL NOT DEPLOY EVEN IF A SUFFICIENTLY SEVERE ACCIDENT WOULD OCCUR AND OCCUPANT PROTECTION PROVIDED BY THE SYSTEM WOULD NOT BE POSSIBLE.
Remedy: DEALERS WILL REWORK THE FRONT PASSENGER SEAT SENSOR MAT SO THAT EXTERNAL FORCE APPLICATION TO THE SEAT DOES NOT CAUSE A CRACK TO THE MAT. THE RECALL BEGAN ON NOVEMBER 6, 2008. BMW WILL ALSO EXTEND THE WARRANTY ON THESE VEHICLES TO 10 YEARS FROM FIRST REGISTRATION WITHOUT ANY MILEAGE LIMIT. OWNERS MAY CONTACT BMW AT 1-800-525-7417.
Campaign 08V384000
4 open NHTSA investigations into this model. Investigations come before recalls, so these are potential defects not yet covered by one.
Rated configuration: 2004 BMW X3 4-DR. w/SAB
The parts named most often across 219 owner complaintsfiled with NHTSA for this make, model and year — the closest free answer to “what is likely to go wrong?”
1 fire
4 crashes · 2 injured
10 fires · 9 injured
2 fires · 1 injured
2 fires · 2 injured
Complaints are self-reported and skew toward problems people find alarming, so treat this as where to look, not a defect rate.
Odometer failed - unable to get this fixed!
AIRBAG LAMP REMIANS ON DUE TO FAILED PASSENGER SEAT OCCUPANCY DETECTION MAT. HONOLULU BMW DEALER CLAIMS RECALL 08V384000 WAS PERFORMED JULY 18, 2008- WHICH IS THE EXACT SAME DATE LISTED IN THE RECALL AS BMW'S REPORT DATE TO NHTSA. THE RECALL CAMPAIGN AND PROCEDURE DID NOT GET PUBLISHED OR BEGIN FOR NEARLY A YEAR LATER. THE RECALL CAMPAIGN ASKS THAT A SMALL STICKER BE AFFIXED ADJACENT TO THE VIN TAG- THERE IS NO STICKER, NOR IS THERE EVIDENCE OF A STICKER EVER HAVING BEEN THERE ( I KNOW WHAT IT SHOULD LOOK LIKE). THE VEHICLE HAS NOT BEEN REPAINTED.
The contact ownd a 2004 BMW X3. The contact stated that while driving at approximately 60 MPH, she dozed off behind the wheel when the vehicle crashed into the rear of a tow truck. As a result, the front end of the vehicle was damaged. The air bags failed to deploy. The contact sustained an injury to the head and bodily soreness. Medical attention was required. No police report was filed. The vehicle was towed to a tow yard however, the vehicle was then towed to the contact’s residence. The vehicle was diagnosed by an air bag specialist and it was determined that the air bag was not connected. The vehicle was not repaired. The dealer was notified of the failure and informed the contact that the air bags failed to deploy due to minimal impact. The vehicle was deemed a total loss by the insurance company. The contact referenced NHTSA Campaign Number 08V384000 (Air Bags). The manufacturer was notified of the failure however, the contact had not received a response back. The failure mileage was unknown.
The airbag light is on our BMW and my 16 years daughter is driving this car. I cannot believe that BMW did not issue a recall. According to Repair Pal: "What are the symptoms of a bad Air Bag Occupant Sensor? Failing occupant sensors can show one of two symptoms. They may stay on at all times, causing the passenger airbags to stay active even when a passenger is not present. Also, they may not operate at all, which prevents the airbags from activating when a passenger is seated in that seating position. Also, for most systems, the airbag or SRS warning light will illuminate on the instrument cluster, prompting the driver to service the system.
CHECK OIL LIGHT CAME ON SO VEHICLE WAS PULLED TO THE SIDE OF THE ROAD. WITHIN SECONDS, SMOKE HAD ENGULFED THE ENGINE BAY. THE ENTIRE VEHICLE WAS ENGULFED IN FLAMES WITHIN A FEW MINUTES.
TL* THE CONTACT OWNED A 2004 BMW X3. THE CONTACT STATED WHILE SHE FELL ASLEEP BEHIND THE WHEEL WHILE DRIVING AT UNKNOWN SPEED, THE VEHICLE CRASHED INTO A TOW TRUCK. THE CONTACT STATED SHE PULLED OVER AFTER THE IMPACT WOKE HER UP. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS TOWED TO A LOT AND A POLICE REPORT WAS NOT FILED. THE CRASH WAS A FRONT END COLLISION. THE DEALER WAS NOT NOTIFIED OF THE CRASH. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VEHICLE WAS DEEMED A TOTAL LOSS. THE VEHICLE WAS PREVIOUSLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 08V384000 (AIR BAGS). *DT*JB
WHILE SITTING AT A RED LIGHT THE CAR SUDDENLY ACCELERATED AND I COULDN'T CONTROL IT OR STOP IT WHILE PUSHING HEAVILY ON THE BRAKE PEDAL. I HIT THE CAR IN FRONT OR ME. THIS HAS HAPPENED MORE THAN ONCE.
WHILE DRIVING MY SUNROOF FLEW OFF THE VEHICLE AND SHATTERED INTO PIECES. THE VEHICLE WAS TRAVELING ABOUT 35 MILES PER HOUR ON A CITY STREET
WATER SEEPS INTO THE VEHICLE FROM AN UNKNOWN LOCATION AND CAUSES A MOLD EFFECT DUE TO SATURATION OF THE FLOOR IN THE BACK PASSENGER AREA. DOOR AND SUNROOF WEATHERSTRIPPING HAVE BEEN PROFESSIONALLY CHECKED AND DEEMED NOT THE CAUSE.
HEADLAMP BULB OUT AND UPON REPLACEMENT IT WAS NOTED THE COATED WIRING TO THE XENON SYSTEM TO RIGHT AND LEFT HEADLIGHT IS BRITTLE (THE WIRES PLASTIC COATING IS FALLING OFF)AND IN SOME PLACES EXPOSED WIRING WAS FOUND. ELECTRICAL TAPE NEED TO WRAP THE WIRING TO AVOID POTENTIAL FIRE. LATE NOTICE TO THIS SITE I WAS UNAWARE TO FILE A REPORT. OTHERS ALSO HAVE COMPLAINED ABOUT THE SAME ISSUES.
DRIVER'S SIDE SEAT WARMER BURNED SKIN AND SCORCHED LEATHER SEAT COVER WHEN TURNED ON.
INSULATION ON WIRING INSIDE THE HEADLIGHT ASSEMBLY IS CRACKING AND FALLING OFF WIRING HARNESS CAUSING A SHORT AND BLOWN FUSE WHILE DRIVING ON CITY STREET.
Showing 12 of 219 complaints.